Abstract:With the continued device scaling and the introduction of new device structures, MOSFET reliability phenomena arising from the hot carrier injection (HCI) stress have received extensive attention from both the academia and the industry community. In this work, the degradations of ultra-scaled silicon on insulator (SOI) MOSFETs under the HCI stress are investigated on devices of different gate lengths (L=30-150 nm). Our experimental data demonstrate that the time evolutions of the threshold voltage change (Vth) under the HCI stress for different gate length devices are the same, and the magnitude of Vth reduces for the shorter devices. The degradation of the device under the HCI stress should be due to both the channel hot carrier (CHC) effect and the bias temperature instability (BTI) effect. The distribution and magnitude of the electric field along the MOSFET's channel are analyzed. It is confirmed that besides the well-known CHC effect in the depletion region close to the drain side, a strong BTI effect co-exists in the channel close to the source side. This degradation mechanism is different from the conventional HCI stress. With the gate length decreasing, the contribution of the aforementioned BTI effect becomes larger, and it dominates in the degradation. One feature of the BTI effects is that the corresponding degradation is small when the gate length is short. This is consistent with our experimental result that the change of Vth is small for the device of short gate length under the accelerated HCI stress. The time evolution of Vth can be described by the equation Vth=A•tn, where A is a constant, t is the stress time, and n is the power law exponent obtained by the curve fitting. In this study, the power law exponent n of pMOSFET is larger than that of nMOSFET. This experimental fact can lead to the point that the BTI effect exists during the HCI stress because the BTI effect in ultra-scaled pMOSFETs is more significant than that in nMOSFETs. The stress-recover experiments of the HCI stress on MOSFTTs show larger recovery in device of shorter gate length. It is found that the ratio of the recovery to the total degradation in the 30 nm gate-length device is almost twice as large as that in the 150 nm device. The degradation from the CHC effect has no recovery, and the larger recovery in the shorter-channel device implies the larger component of the BTI degradation. Another intriguing fact is that our experimental result on SOI MOSFET is inconsistent with the recently reported result on FinFET. We argue that the reported stronger HCI degradation in FinFET may not be ascribed only to the stronger electric field in the shorter channel, but also to the fact that the FinFET' channel is three-dimensionally surrounded by the gate dielectric. This kind of three-dimensional structure significantly increases the chance for electrons or holes to be injected into the dielectric layer. Therefore the HCI reliability of planar SOI MOSFETs may be better than that of FinFETs at the same level of gate length. In conclusion, the BTI effect is an important source of the degradation during the HCI stress in ultra-short-channel device, and it is no more negligible in analyzing the underlying physical mechanism.

Optimized Design of HCE Degradation Induced by Tilt of Halo

Analysis and Optimization of Sub-100 Nm NMOS with Halo

The Effect of Halo Implantation on the Performance of 50 nm NMOS Device

Gate Length Dependence of Hot Carrier Injection Degradation in Short Channel Silicon on Insulator Planar Mosfet

Evaulation the Degradation in Nmosfets with HfO2 Gate Dielectric and Interfacial Layer by 3D Kinetic Monte-Carlo Method

Degradation induced by hot carrier and cold carrier in 65-nm NMOSFETs with enclosed gate and two-edged gate layouts

Self-heating Enhanced HCI Degradation in Pldmosfets

Valence-band Tunneling Enhanced Hot Carrier Degradation in Ultrathin Oxide Nmosfets

Performance and Analytical Modelling of Halo-Doped Surrounding Gate Mosfets

The Simulation and Analysis of Hot Carrier Effect in LDD MOS

New Insights into the Interface Trap Generation during Hot Carrier Degradation: Impacts of Full-band Electronic Resonance, (100) vs (110), and nMOS vs pMOS

Understanding Hot Carrier Degradation and Variation in FinFET Technology

Analytical and Numerical Study of the Impact of Halos on Surrounding-Gate Mosfets

Optimization Of A Sub 0.1-Mu M Asymmetric Halo Soi-Mosfet For High Performance Digital Applications

Analytical Model for Threshold Voltage of Hetero-Gate SOI MOSFET with Asymmetric Halo

Hot Carrier Degradation-Induced Dynamic Variability in FinFETs: Experiments and Modeling

Performance Optimization of Lateral Algan/Gan Hemts with Cap Gate on 150-Mm Silicon Substrate

Analytical Modeling and Simulation of Dual-Material Surrounding-Gate Metal–Oxide–Semiconductor Field Effect Transistors with Single-Halo Doping

Process optimization for random threshold voltage variation reduction in nanoscale MOSFET by 3D simulation

Enhanced Performances of AlGaN/GaN HEMTs with Dielectric Engineering of HfZrOx

Metal Boundary Effect Mitigation by HKMG Thermal Process Optimization in FinFET Integration Technology