Abstract:This study was focused on the long-term corrosion performance of coated AA2024 and AA5119 aluminum alloys in the atmosphere and coastal environment after 4, 8 and 12 years of exposure. Structural analyses of samples using SEM and XRD analyses revealed that the corrosive surface area of alloys increased with increasing the atmospheric exposure time, and formation of Al(OH)3 as corrosion product on the corroded surface layer of both atmospheric exposed 12 years samples. Comparison between the exposed 12 years samples showed that the higher level of impurities, deeper pits and exfoliation corrosion were observed for exposed AA2024 sample which related to the destruction of anodic oxide film due to pitting attack and decrease of protection capability of the epoxy coated layer, and lower level of impurities and corrosion on the AA5119 sample can be related to the presence of lower Si/Mg molar ratio in the alloy. Electrochemical impedance studies showed the decrease in corrosion resistance with the increase in the duration of atmospheric exposure. Results also showed that deposition of corrosion products on the surface of AA5119 alloy can act as a protective layer through preferentially filling the pores/defects. Therefore, the observations indicate the corrosion resistance of aluminum alloys is significantly dependent on the composition and created crystal defects in the manufacturing process of alloys. Coated AA5119 aluminum alloys show a higher corrosion resistance than that AA2024 in long-term atmosphere exposure in the coastal environments.

Investigation of Exfoliation Corrosion of Rolled Aa8090 Al-Li Alloy Using Electrochemical Impedance Spectroscopy

Exfoliation Corrosion Susceptibility of 8090 Al-Li Alloy Examined by Electrochemical Impedance Spectroscopy

ELECTROCHEMICAL IMPEDANCE SPECTROSCOPY OF Al ALLOYS DURING EXFOLIATION CORROSION

Exfoliation Corrosion of Al-Li Alloy 2090-T6 in Exco Solution: A Study of Electrochemical Noise and Electrochemical Impedance Spectroscopy

Electrochemical impedance spectroscopy during corrosion process of 8090 Al-Li alloy in EXCO solution

Exfoliation Corrosion of Aluminum Alloy AA7075 Examined by Electrochemical Impedance Spectroscopy

Electrochemical Impedance Spectroscopy Analysis on Aluminum Alloys in EXCO Solution

EIS Investigation of the Deposition of Trivalent Chromium Coatings on Al 6063 Alloy

INFLUENCE OF TENSILE STRESS ON EXFOLIATION CORROSION AND ELECTROCHEMICAL IMPEDANCE SPECTROSCOPY OF 7075al - ALLOY

The Effect of Applied Tensile Stress on the Exfoliation Corrosion of 7075‐T6 Alloy

REVIEW ON EXFOLIATION SUSCEPTIBILITY OF ALUMINIUM ALLOYS AND QUANTITATIVE MEASUREMENT METHOD

Electrochemical Impedance Spectra for the Corrosion of Porous Cu-35mass%Ni-(5,10)mass%Cr Alloys in Molten (0.62li,0.38k)2co3 at 650 °C in Air

Exfoliation Corrosion of As-Extruded Mg–1Li–1Ca: the Influence of the Superficial Layer

ELECTROCHEMICAL FEATURES OF THE CORROSION OF AN ALUMINUM-LITHIUM ALLOY IN 3.0% NaCl SOLUTION

Electrochemical Impedance Spectroscopy Analysis on the Electrochemical Dissolution of Aluminum in an Alkaline Solution

Corrosion Electrochemical Characteristics of Red Iron Oxide Pigmented Epoxy Coatings on Aluminum Alloys

Investigation of Long-term Corrosion of AA2024 and AA5119 Aluminum Alloys under chromate coating in Marine Atmosphere by Electrochemical Impedance Technology

Impedance Models of Epoxy Coated LY12 Aluminum Alloys in NaCl Solution

Corrosion Behaviour of Ly12 Alloy under Thin Electrolyte Films

In-situ visualization of corrosion behavior of Al CoCrFeNi high-entropy alloys during electrochemical polarization

EIS Analysis on the Anodic Dissolution Process of Pure Aluminum in an Alkaline Solution