Abstract:The group-Ⅲ nitrides and their related ternary alloys have been becoming the most attractive material for light emitting diodes (LEDs) and laser diodes (LDs) in the UV and blue spectral range. However, the origins of the yellow luminescence (YL), which is commonly observed in almost undoped and n-type GaN, remain unclear. The nature and the role of initial nitridation of sapphire surface and the generation of threading dislocation (TD) are ambiguous too. It is a possible way to resolve the above problems by studying the microstructures and optical properties combining the growth conditions. In this work, two kinds of GaN films were grown by MOCVD under different initial nitridation time (180 seconds for Sample A, and 90s for Sample B). The growth temperature is about 950℃. The cross-sectional transmission electron microscope (TEM) is performed near the GaN/sapphire interface. Corresponding the growth processes, there are three zones in the GaN layer: buffer layer, zone and sound zone. There are haystack-like domains in the faulted zone, in which there are high density of extended defects. The thickness of the faulted zone is about 0.4μm. Just above this region, the defects density is reduced sharply, and the quality of the layer is improved, which is identified by electron diffraction (ED) patterns. In comparison, Sample A shows about an order lower density of extended defects than Sample B, their columnar diameter is larger and its ED pattern is sharper, too. The buffer layer of Sample B is more smooth than Sample A. The appropriate rougher morphology of the buffer layer may cause that the structural disorder between the high-temperature (HT) grown island and the buffer layer is accommodated by Frank and Shockley partial dislocations. However, the TD is likely to propagate into the HT GaN from the smooth surface of the buffer layer grown after extensively nitridation of substrate. According to the position and width of X-ray diffraction peaks of (0002) and (0004), the size of crystalline grain, D and the residual strain could be calculated. The values of(D,e in)of Sample A and B are (175nm,0.167%) and (90nm,0.141%), respectively. Small size of crystalline grain may be advantageous to relieve the lattice and thermal mismatch stress, but it lead to higher density of extended defects. The width of GaN (0002) reflections of Sample A is 4min lower than that of Sample B. This result may be due to the lower screw TD. The higher density of screw TD may widen the GaN (0002) peak in X-ray rocking curve. In room temperature PL spectra, the ratio of band-edge emission intensity to YL one of Sample A is 3 orders larger than that of Sample B. Furthermore the YL in Sample B is stronger and has fine structure, while that in Sample A is nearly invisible in the PL spectrum. The GaN epilayer with high quality exhibits almost no YL emission. It is well known that the YL corresponds to the deformed crystal structure. We assigned that the screw TD and mixed TD are attributed to the YL referring to our XRD results.

Defects in IIINitrides Epilayers

Characterisation of Defects at Non-Polar GaN/InGaN Junctions in Novel Materials for Application in Light Emitting Diodes

Defects in GaN Films Studied by Positron Annihilation Spectroscopy

The Origin and Evolution of V-defects in InxAl1−xN Epilayers Grown by Metalorganic Chemical Vapor Deposition

Structural Analysis in Low-V-defect Blue and Green GaInN/GaN Light Emitting Diodes

Study of the Defects in GaN Epitaxial Films Grown on Sapphire by HVPE

Transmission Electron Microscopy Study of Epitaxial InN Thin Films Grown on C -Plane Sapphire

Microstructural and Optical Properties of GaN Films on Nitrided Sapphire Substrates

Luminescence properties of defects in GaN

Nanopipes in undoped AlGaN epilayers

Emission from Defects in Thin Gan Epilayers Grown on Vicinal 4H-Sic Substrates

Crystalline Quality of InxAl1-xN with Different Indium Contents Around Lattice-Matched to GaN

Structure, defects, and optical properties of commensurate GaN/ZnGeN2/GaN double heterojunctions

Study of Defects and Nano-patterned Substrate Regulation Mechanism in AlN Epilayers

Influence of Point Defects on Optical Properties of GaN-based Materials by First Principle Study

Etch Pits and Threading Dislocations in GaN Films Grown by Metal-Organic Chemical Vapour Deposition

Observation of Optically-Active Metastable Defects in Undoped Gan Epilayers

Defect States in Cubic GaN Epilayer Grown on GaAs by Metalorganic Vapor Phase Epitaxy

Structural Characterization of Homoepitaxial Blue GaInN/GaN Light-Emitting Diodes by Transmission Electron Microscopy

Molecular dynamics studies of defect formation during heteroepitaxial growth of InGaN alloys on (0001) GaN surfaces

Dislocation and Indium Droplet Related Emission Inhomogeneities in InGaN LEDs