Abstract:ABSTRACT A series of ethylene, propylene homopolymerizations, and ethylene/propylene copolymerization catalyzed with rac ‐Et(Ind) 2 ZrCl 2 /modified methylaluminoxane (MMAO) were conducted under the same conditions for different duration ranging from 2.5 to 30 min, and quenched with 2‐thiophenecarbonyl chloride to label a 2‐thiophenecarbonyl on each propagation chain end. The change of active center ratio ([C * ]/[Zr]) with polymerization time in each polymerization system was determined. Changes of polymerization rate, molecular weight, isotacticity (for propylene homopolymerization) and copolymer composition with time were also studied. [C * ]/[Zr] strongly depended on type of monomer, with the propylene homopolymerization system presented much lower [C * ]/[Zr] (ca. 25%) than the ethylene homopolymerization and ethylene–propylene copolymerization systems. In the copolymerization system, [C * ]/[Zr] increased continuously in the reaction process until a maximum value of 98.7% was reached, which was much higher than the maximum [C * ]/[Zr] of ethylene homopolymerization (ca. 70%). The chain propagation rate constant ( k p ) of propylene polymerization is very close to that of ethylene polymerization, but the propylene insertion rate constant is much smaller than the ethylene insertion rate constant in the copolymerization system, meaning that the active centers in the homopolymerization system are different from those in the copolymerization system. Ethylene insertion rate constant in the copolymerization system was much higher than that in the ethylene homopolymerization in the first 10 min of reaction. A mechanistic model was proposed to explain the observed activation of ethylene polymerization by propylene addition. © 2016 Wiley Periodicals, Inc. J. Polym. Sci., Part A: Polym. Chem. 2017 , 55 , 867–875

Studies on Kinetics of Ethylene-Propylene Gas-Phase Copolymerization

Modeling of an Industrial Polycondensation Process for Polyethylene Terephthalate

Kinetics Of Propylene Bulk Polymerization With A Spherical Ziegler-Natta Catalyst

Kinetic Modeling of C2–C7 Olefins Interconversion over ZSM-5 Catalyst

Kinetic Parameter Estimation for Linear Low-Density Polyethylene Gas-Phase Process from Molecular Weight Distribution and Short-Chain Branching Distribution Measurements

Quality Predicting Models for Ethylene Terpolymerization to High-Performance Polyethylene

Molecular Dynamics Simulation of in Situ Polymerization: Chain Conformation Transition

Important Mesoscale Phenomena in Gas Phase Fluidized Bed Ethylene Polymerization

Modeling Ethylene/Butene Copolymerization with Multi‐site Catalysts: Parameter Estimability and Experimental Design

Modeling and Kinetics of Tandem Polymerization of Ethylene Catalyzed by Bis(2-Dodecylsulfanyl-ethyl)amine-crcl3 and Et(Ind)2ZrCl2

Estimation of the Chain Propagation Rate Constants of Propylene Polymerization and Ethylene‐1‐hexene Copolymerization Catalyzed with MgCl2‐supported Ziegler–Natta Catalysts

Copolymerization Kinetics of Ethylene Oxide and Propylene Oxide

Kinetic study on copolymerization of ethylene and 1-hexene catalyzed by Cp2ZrCl2/MAO catalytic system

Simultaneous Simulation of Ethylene Slurry Polymerization Process

Study on the kinetics of supported catalysts for propylene polymerization in slurry

Kinetics and Mechanism of Metallocene‐catalyzed Olefin Polymerization: Comparison of Ethylene, Propylene Homopolymerizations, and Their Copolymerization

Kinetics of ethylene polymerization in gas phase with a spherical Ziegler-Natta catalyst

Study on Polymerization of Ethylene with Cp2zrcl2/Aluminoxanes

Studies on Vocl3/Mgcl2/Nay/Al(2)Et(3)Cl(3) Complex Support Catalysts for the Copolymerization of Ethylene and Propylene

Modeling of the Molecular Weight Distribution and Short Chain Branching Distribution of Linear Low-Density Polyethylene from a Pilot Scale Gas Phase Polymerization Process

Comparative Study on Kinetics of Ethylene and Propylene Polymerizations with Supported Ziegler–Natta Catalyst: Catalyst Fragmentation Promoted by Polymer Crystalline Lamellae