Abstract:Measurement of particle velocity in fluidized beds is always technically difficult. A new method based on cross-correlation principle was proposed to calculate time-averaged velocity of particles. Considering the different reliabilities of signal segments, a cross-correlation coefficient was introduced into the formula for calculating time-averaged velocity. A PV6D optical fiber probe was used to obtain original signals in a fluidized bed with 200 mm i.d., and the time-averaged velocities calculated from three different methods were compared. The calculated particle volume flow rates based on different velocity calculating methods indicate that the method proposed in this paper is more reliable. Based on this method, particle time-averaged velocity was measured at different heights in the transition section of a turbulent fluidized bed. A modified three-zone drag law model was used to predict the flow structure of particles with clustering behavior. The experimental and simulation results both indicate that, from the transition section to the dilute section, particle velocity of the core region rises at first and then declines, the radial velocity distribution changes from a steep curve to a flat one, and then becomes steep again. This result depends on both solid concentration distribution and gas velocity distribution.

MEASUREMENT OF 3-DIMENSION FLOWING VELOCITY OF FLUE GAS BY THE CROSS CORRELATION METHOD

Particle Velocity Measurements in Transition Section of Turbulent Fluidized Beds Using Optical Fiber Probe and CFD Simulation

Measuring Flow Velocity Distribution in Microchannels Using Molecular Tracers

A new method for the velocity measurement of gas-liquid two-phase flow

A New Method for Flow Rate Measurement in Millimeter-Scale Pipes.

A Device and Method For Flowrate Measurement of Fluid in Small Channel Based on C~4D Technique

A Model-Based Transit-Time Ultrasonic Gas Flowrate Measurement Method

Analysis of influencing factors of complex fluid velocity measurement based on cross correlation algorithm

An Experiment-Based Comparative Investigation of Correlations for Microtube Gas Flow

STUDY OF ZERO-CROSSING POLARITY CORRELATION FOR VELOCITY MEASUREMENT OF HIGH TEMPERATURE FLUE GAS

Flowrate measurement of air-water two-phase flow using an Electrical Resistance Tomography sensor and a Venturi meter

Measurement of Bubble Velocity Using Capacitively Coupled Contactless Conductivity Detection (C4D) Technique

Parameter Measurement System of Taylor Flow in Small Channels Based on Photodiode Array Sensors.

A New Contactless Method For Velocity Measurement Of Bubbleand Slug In Millimeter-Scale Pipelines

Development of a Gas Flow Sensor Based on FS5 Hot-Film Probe

Investigation of Oil-Air Two-Phase Mass Flow Rate Measurement Using Venturi and Void Fraction Sensor

MEASUREMENT OF PARTICLE VELOCITY IN TWO-PHASE FLOW BY OPTICAL CROSS-CORRELATION METHOD

A New Method for Velocity Measurement of Gas-Liquid Two-Phase Flow Based on C~4D Technique

Study of Effects of Digital Filtering and Sensor Characteristics on Velocity Measurement by Correlation Method

Measurement of Bubble Velocity Based on C~4D Technique

Study on new gas flow sensor based on hot-film probe