Abstract:Measurement of particle velocity in fluidized beds is always technically difficult. A new method based on cross-correlation principle was proposed to calculate time-averaged velocity of particles. Considering the different reliabilities of signal segments, a cross-correlation coefficient was introduced into the formula for calculating time-averaged velocity. A PV6D optical fiber probe was used to obtain original signals in a fluidized bed with 200 mm i.d., and the time-averaged velocities calculated from three different methods were compared. The calculated particle volume flow rates based on different velocity calculating methods indicate that the method proposed in this paper is more reliable. Based on this method, particle time-averaged velocity was measured at different heights in the transition section of a turbulent fluidized bed. A modified three-zone drag law model was used to predict the flow structure of particles with clustering behavior. The experimental and simulation results both indicate that, from the transition section to the dilute section, particle velocity of the core region rises at first and then declines, the radial velocity distribution changes from a steep curve to a flat one, and then becomes steep again. This result depends on both solid concentration distribution and gas velocity distribution.

MEASUREMENT OF PARTICLE VELOCITY IN TWO-PHASE FLOW BY OPTICAL CROSS-CORRELATION METHOD

Particle Velocity Measurements in Transition Section of Turbulent Fluidized Beds Using Optical Fiber Probe and CFD Simulation

Measurement of 2-Dimension Particle Velocity by Using-Correlation Technique on Optical Transmission Signals

Measuring Flow Velocity Distribution in Microchannels Using Molecular Tracers

Optical measurement of small channel two-phase flow based on PSD principle

A new method for the velocity measurement of gas-liquid two-phase flow

Measurement of Bubble Velocity Using Capacitively Coupled Contactless Conductivity Detection (C4D) Technique

Analysis of influencing factors of complex fluid velocity measurement based on cross correlation algorithm

Measurement of bubble/slug velocity and size in vertical pipe based on optical cross-correlation method

Optical Measurement System for Two-Phase Flow in Horizontal Small Tube Based on Photodiode Arrays

Cross-sectional Phase Distribution Measurement of Slug Flow in Small Channels

MEASUREMENT OF 3-DIMENSION FLOWING VELOCITY OF FLUE GAS BY THE CROSS CORRELATION METHOD

Measurement of Two-Phase Velocities in Bubble Flows Using Laser Doppler Velocimetry

Investigation of Oil-Air Two-Phase Mass Flow Rate Measurement Using Venturi and Void Fraction Sensor

A New Method for Velocity Measurement of Gas-Liquid Two-Phase Flow Based on C~4D Technique

Transverse Flow Velocity Quantification Using Optical Coherence Tomography with Correlation

Measurement of Bubble Velocity Based on C~4D Technique

Flow Velocity Measurement Technology for Open Fluid Field Based on Optical Cross-correlation Method

Simultaneous Measurement Of Particle Velocity And Size Based On Gray Difference And Autocorrelation

Higher-order Cross-Correlation-based Doppler Optical Coherence Tomography

Simultaneous Measurement of Particle Velocity and Size Based on Gray Difference and Ai]tocorrelation