Abstract:Selective Catalytic Reduction (SCR) system can efficiently remove NOx in coal-fired power plant, while raise SO3 concentration in the flue gas. Alkaline sorbent injection is a major approach to remove SO3. Experiments were conducted to study the SO3 absorption performance of alkaline sorbent. The SO3 absorption performance of the three alkaline sorbents was Na2CO3 > Ca(OH)(2) approximate to Mg(OH)(2). The ratio of SO3 absorption rate to SO2 absorption rate for Na2CO3 increased with the increasing temperature. The key parameters on the SO3 absorption performance of Na2CO3 were studied. The SO3 absorption by Na2CO3 was increased by 72.7% with increasing temperature from 150 degrees C to 300 degrees C, and the temperature had little influence on SO3 absorption above 300 degrees C. The increasing SO3 concentration and decreasing particle size of Na2CO3 enhanced SO(3 )absorption. However, when the average particle diameter was less than 50 the SO3 absorption was no longer significantly increased. The increasing CO2 concentration slightly reduced the SO3 absorption. After adding vapor into the flue gas, the SO3 absorption was obviously increased below 300 degrees C. The SO3 absorption variation above 300 degrees C was similar to the condition without vapor. When reaction temperature was 300 degrees C or above and reaction time was less than 20 min, external diffusion became the control step for SO3 absorption. On the basis of external diffusion control model, the mass transfer coefficient slightly increased from 1.68 x 10(-3)m/s to 1.75 x 10(-3) m/s when the reaction temperature increased from 300 degrees C to 400 degrees C.

Study on SO2 removal of calcium sorbent mixed with pulverized coal ash

Study On So2 Removal During Pulverized-Coal Combustion

Study on desulfurization reaction characteristic of calcium-based sorbents

EXPERIMENTAL STUDIES ON DESULFURIZATION OF CALCIUM BASED SORBENT IN O2/CO2 COAL COMBUSTION

Two-Stage Desulfurization Of Calcium-Based Sorbents During Coal Combustion In The Chain-Grate Furnace

[Study on the Calcium-Based Sorbent for Removal Fluorine During Coal Combustion].

Experimental Study of Desulfurization of Chemical-Loping Combustion of Coal With Calcium-based Oxygen Carrier

Experimental Study On Desulfurization Of Compound Sulfur Sorbents Of Caco3 And Fly Ash

STUDY ON TWO-STAGE DESULFURIZATION TECHNOLOGY WITH PREMIXED AND INJECTED SORBENTS IN COAL-FIRED BOILERS

Effect of impurities on desulfurization properties of limestone during coal gasification

An Experimental Study of Flue Gas Desulfurization by Direct Application of Fly Ash with High Calcium Content

Study on the sorbent for removal of fluorine/sulfur from burning coal

Experimental study of steam reactivation of calcium-based sorbent for dry FGD process

E211 STAGED SORBENT INJECTION UNDER AIR-STAGED COMBUSTION CONDITIONS FOR SO_2 REDUCTION IN A PULVERIZED COAL FIRED BOILER

Effect of Calcium Oxide Additive on the Performance of Iron Oxide Sorbent for High-Temperature Coal Gas Desulfurization

Experimental Study on the Removal of SO3 from Coal-Fired Flue Gas by Alkaline Sorbent

Experimental Study on Additive Enhanced Limestone Wet Flue Gas Desulfurization

Staged Desulphurization by Direct Sorbent Injection in Pulverized-Coal Boilers

INTERACTION BETWEEN SO2 FROM FLUE GAS AND SORBENT PARTICLES IN DRY FGD PROCESSES

The Study of the Effect of Calcium Base on the Coal Ash Fusibility

Study on Formation of SO2 and NOx in Coal Combustion with Limestone Injection