Abstract:A novel design of the gas inlet system in a diamond microwave plasma chemical vapor deposition growth chamber has been reported in this paper. The design is targeting for high-quality, high-speed, and high-efficiency diamond material fabrication. By introducing a gas inlet hole into the susceptor, we expand the ways of gas introduction for diamond growth. After extensive numerical and experimental investigation, we have found that the introduction of methane and doping gas inlet from the hole of below while the hydrogen from the top is feasible for realizing the target. The growth and doping species could be confined around the substrate, making efficient usage of the precursors. The plasma state change caused by the difference of the gas inlet modes has been ascribed to the resulted gas distribution in the chamber. The measured growth rate has been increased to 32 μm/h, which is 16 times higher than traditional gas inlet configuration. Meanwhile, a large improvement of the nitrogen doping concentration has been achieved. Besides, with the increase of growth rate and nitrogen incorporation efficiency, the crystal quality and surface morphology keep in an acceptable degree. In this mode, the dual gas flow system can perfectly solve the contradiction among the crystal quality, growth rate, and doping efficiency, commonly existing during the material fabrication process, the chamber contamination could be significantly suppressed due to the constrained distribution of methyl and doping species, making the fabrication cost much lower. The results of repetitive experiments indicate that other residual impurities present in the chamber of MPCVD could likely regulate the threshold concentration of nitrogen required for accelerating the growth rate during the nitrogen doped diamond growth, which have a significant effect on the diamond growth.

A novel microwave plasma reactor with a unique structure for chemical vapor deposition of diamond films

Microwave plasma modelling in clamshell chemical vapour deposition diamond reactors

Diamond-Like Carbon Thin-Film Deposition Using A Magnetically Confined Rf Pecvd System

An innovative gas inlet design in a microwave plasma chemical vapor deposition chamber for high-quality, high-speed, and high-efficiency diamond growth

Design and simulation of a novel MPCVD reactor with three-cylinder cavity

Large Area Single-Crystal Diamond Synthesis by 915 MHz Microwave Plasma-Assisted Chemical Vapor Deposition

Scanning Deposition Method for Large-Area Diamond Film Synthesis Using Multiple Microwave Plasma Sources

Deposition of uniform diamond films on three dimensional Si spheres by using faraday cage in MPCVD reactor

Growth of single-crystal diamond by microwave plasma CVD with high precursor utilization using cyclic gas injection and control of carbonaceous species content with optical emission spectroscopy

Novel Diamond Films Synthesis Strategy: Methanol and Argon Atmosphere by Microwave Plasma CVD Method Without Hydrogen

Formation of Diamond-Like Carbon Coatings by Chemical Deposition in High Density Plasma

High Efficiency of Boron Doping and Fast Growth Realized with a Novel Gas Inlet Structure in Diamond Microwave Plasma Chemical Vapor Deposition System

Very high growth rate chemical vapor deposition of single-crystal diamond.

Developments in Microwave Plasma Chemical Vapor Deposition Technology for Preparing High Quality Diamond Films

Research on Excimer Laser Induced Chemical Vapor Deposition of Diamond Films

A Study of Diamond-Like Carbon Thin Films Prepared by Microwave Plasma Chemical Vapour Deposition

Deposition of nano-diamond-like carbon films by an atmospheric pressure plasma gun and diagnostic by optical emission spectrum on the process

High Efficiency Deposition of Diamond Film by Hot Filament Chemical Vapor Deposition

Enhanced Growth Of High Quality Single Crystal Diamond By Microwave Plasma Assisted Chemical Vapor Deposition At High Gas Pressures

Hot Spot Formation In Microwave Plasma Cvd Diamond Synthesis

Microwave power and chamber pressure studies for single-crystalline diamond film growth using microwave plasma CVD