Abstract:Based on the self-terminating thermal oxidation-assisted wet etching technique, two kinds of enhancement mode Al2O3/GaN MOSFETs (metal–oxide–semiconductor field-effect transistors) separately with sapphire substrate and Si substrate are prepared. It is found that the performance of sapphire substrate device is better than that of silicon substrate. Comparing these two devices, the maximum drain current of sapphire substrate device (401 mA/mm) is 1.76 times that of silicon substrate device (228 mA/mm), and the field-effect mobility (μ FEmax) of sapphire substrate device (176 cm2/V⋅s) is 1.83 times that of silicon substrate device (96 cm2/V⋅s). The conductive resistance of silicon substrate device is 21.2Ω ⋅mm, while that of sapphire substrate device is only 15.2Ω ⋅mm, which is 61% that of silicon substrate device. The significant difference in performance between sapphire substrate and Si substrate is related to the differences in interface and border trap near Al2O3/GaN interface. Experimental studies show that (i) interface/border trap density in the sapphire substrate device is one order of magnitude lower than in the Si substrate device, (ii) Both the border traps in Al2O3 dielectric near Al2O3/GaN and the interface traps in Al2O3/GaN interface have a significantly effect on device channel mobility, and (iii) the properties of gallium nitride materials on different substrates are different due to wet etching. The research results in this work provide a reference for further optimizing the performances of silicon substrate devices.

Characteristics of Submicron-Footprint TiO2 Based AlGaN/GaN MOSHEMT on SiC Substrate

Low Leakage Current and High-Cutoff Frequency AlGaN/GaN MOSHEMT Using Submicrometer-Footprint Thermal Oxidized TiO2/NiO As Gate Dielectric

A high breakdown voltage AlGaN/GaN MOSHEMT using thermal oxidized Al-Ti as the gate insulator

Direct Current and Microwave Characteristics of Sub-Micron Algan/Gan High-Electron-Mobility Transistors on 8-Inch Si(111) Substrate

AlGaN/GaN HEMTs with thermal oxidation treatment for microwave power applications

High Breakdown AlGaN/GaN MOSHEMT with Thermal Oxidized Ni/Ti As Gate Insulator

Improved Electrical and Deep-UV Sensing Characteristics of Al2O3-Dielectric AlGaN/AlN/SiC MOS-HFETs

Al 2 O 3 -Dielectric InAlN/AlN/GaN ${\Gamma}$ -Gate MOS-HFETs With Composite Al 2 O 3 /TiO 2 Passivation Oxides

First-Principles-Based Quantum Transport Simulations of High- Performance and Low-Power MOSFETs Based on Monolayer Ga2O3

Demonstration of Submicron-Gate AlGaN/GaN High-Electron-Mobility Transistors on Silicon with Complementary Metal–Oxide–Semiconductor-Compatible Non-Gold Metal Stack

Enhanced Device Performance of AlGaN/GaN HEMTs Using Thermal Oxidation of Electron-Beam Deposited Aluminum for Gate Oxide

1-mm gate periphery AlGaN/AlN/GaN HEMTs on SiC with output power of 9.39W at 8GHz

Simulation and analysis of high breakdown voltage AlGaN/GaN MOSHEMTs with TiO2/Al2O3 gate dielectric

GaN metal-oxide-semiconductor field-effect-transistor with atomic layer deposited Al2O3 as gate dielectric

CMOS-compatible Ehancement-Mode GaN-on-Si MOS-HEMT with High Breakdown Voltage (930V) Using Thermal Oxidation and TMAH Wet Etching

High Performance Submicron Inversion-Type Enhancement-Mode InGaAs MOSFETs with ALD Al2O3, HfO2 and HfAlO As Gate Dielectrics

Physical Analysis of Normally-off ALD Al2O3/GaN MOSFET with Different Substrates Using Self-Terminating Thermal Oxidation-Assisted Wet Etching Technique

5.3A/400V Normally-off AlGaN/GaN-on-Si MOS-HEMT with High Threshold Voltage and Large Gate Swing

Growth and Characterization of 0.8-Μm Gate Length AlGaN/GaN HEMTs on Sapphire Substrates

High Performance AlGaN/GaN Power Switch with Si3N4insulation

Fabrication of 150-Nm Al 0.48 in 0.52 As/Ga 0.47 in 0.53 As Mhemts on GaAs Substrates