Abstract:27Al and 29Si solid-state NMR spectra and X-ray diffraction (XRD) patterns were obtained for α-SiAlON powders prepared by combustion synthesis, according to which the phase transformation and structure evolution of α-SiAlON were studied. It was found that in α-SiAlON 29Si chemical shift values (−48<δSi<−47) were close to those in β-Si3N4 and α-Si3N4, indicating that Si atoms kept SiN4 coordination to a large extent in α-SiAlON despite the presence of O atoms. Dissimilarly, 27Al chemical shift values in α-SiAlON deviated clearly from that corresponding to AlN4 coordination (δAl∼112) and occurred in a range from δAl 95.5 to 99.9, which should be assigned to tetrahedral AlOxN4−x (0≤x≤4) coordination. The broadening effect of AlOxN4−x peaks was noticed, which was suggested to induced by slight dispersion of α-SiAlON compositions. 27Al resonances assigned to AlO4 or AlO6 were also observed, revealing the existence of glassy phase in combustion products. By comparing the intensities of AlO4 and AlO6 resonance peaks, it was found that the composition and structure of the co-existing liquid assisting α-SiAlON formation were not constant but varied with temperature in combustion synthesis. In addition, with CaF2 used as Ca-source α-SiAlON with low oxygen contents (n<m/2) were prepared, and it was found that there was a low threshold of oxygen content only beyond which α-SiAlON could be formed.

Synthesis and characterization of single-crystalline phase Li-α-Sialon

Synthesis And Characterization Of Single-Crystalline Phase Li-Alpha-Sialon

Synthesis of alpha-Sialon by High Temperature Nitridation Reaction

Synthesis of Rod-Like Α-Sialon by Carbothermal Reduction-Nitridation

Synthesis of α-Sialon by High Temperature Nitridation Reaction

Synthesis of Sialon Powders from Aluminium Dross and Fly Ashes

Dilithium Dialuminium Trisilicate Crystalline Phase Prepared from Coal Fly Ash

Study on Synthesizing Diphase Sialon from Lower Al2O3 Bauxite by Carbothermal Reduction-Nitridation

In‐situ synthesis of 15R‐Sialon from Al‐Si 3 N 4 ‐Al 2 O 3 composite at 1500°C via liquid‐phase sintering

Preparation and formation mechanism of elongated (Ca, Dy)-α-sialon powder via carbothermal reduction and nitridation

Synthesis of Environment-Friendly Sialon/SiC Multiphase Ceramics from Cheap Nonmetallic Resources

Synthesis of Prismatic Β-Sialon from the Precursor of SBA-15 Incorporated with Al(NO3)3 Via Carbothermal Reduction Nitridation

Preparation And Formation Mechanism Of Elongated (Ca,Dy)-Alpha-Sialon Powder Via Carbothermal Reduction And Nitridation

Combustion Synthesis of Rod-Like Α-Sialon Seed Crystals

Combustion synthesis of rod-like Yb alpha-sialon powders

Effect of Alumina Contents on the Synthesis of ZrN-Sialon from Zircon

Preparation of (ca+m) (m=mg, Yb, Sr) Co-Doped Α-Sialon Powders by Combustion Synthesis

Effects Of Technical Parameters On The Phase Composition And Microstructure Of Yb Alpha-Sialon Prepared By Combustion Synthesis

Solid-state NMR and XRD study of α-SiAlON powders prepared by combustion synthesis

Solid-state NMR Characterization of Β-Sialons from Self-Propagating High-Temperature Synthesis

Fabrication of (ca + Yb)- and (ca + Sr)-stabilized Α-Sialon by Combustion Synthesis