Abstract:Experiments have been carried out to separate elements of magnesium and lithium from seawater to produce a lithium concentrate product that is free of magnesium through sodium silicate precipitation processes. In this study, the sample used was seawater taken from the Ancol Lagoon Area, North Jakarta. The sea water used contains 0.1674 ppm lithium ions and 1761 ppm magnesium ions with a high Mg/Li ratio of 10521. The seawater containing high levels of magnesium is not suitable as a raw material for for the manufacture of lithium carbonate (battery active ingredient) prior to initial processing. The research variable was the volume of sodium silicate solution added by 10 ml, 20 ml, 30 ml, 40 ml, 50 ml, 60 ml, 70 ml, and 100 ml which were equivalent to 13%, 27% 40%, 53%, 67%. , 80 %, 93%, and 107% stoichiometry of magnesium ion and the technique of adding sodium silicate solution included a single stage and multi-stages. From the experimental results, it can be seen that the most effective addition of sodium silicate is the addition of 80% stoichiometry. The sodium silicate precipitation process succeeded in separating magnesium ions and lithium ions from seawater as indicated by a decrease in the Mg/li ratio from 10521 to 64. The obstacle in this study was that there were still many lithium ions that were also precipitated with magnesium silicate during the precipitation process so that the lithium lost in the filtrate reached 82.26% in the single stage process. Therefore, a multi-stage process was carried out with 6 stages of the process that the addition of sodium silicate for each stage was 1/6 of the volume of sodium silicate solution at single stage optimum conditions. The results obtained from the multi-stage process were able to reduce the lithium ion lost in the filtrate to 76.54%. From the results of the study, it can be concluded that efforts to reduce the percentage of lithium ions lost in the filtrate product need to be carried out through the development of a sodium silicate precipitation process.

The Influence of Separation and Scrubbing from Flocculant in Preparation of High Purity Magnesium Oxide by Milk of Lime Method

The construction of an efficient magnesium-lithium separation thin film composite membrane with dual aqueous-phase monomers (PIP and MPD)

INFLUENCE OF HIGH-MOLECULARS COMPOUNDS OF DIFFERENT NATURE ON THE EFFICIENCY OF PURIFICATION THE MOTHER LIQUOR OF MAGNESIUM SULFATE PRODUCTION FROM IMPURITIES Fe3+, Al3+ AND Cr3+ BY ELECTROFLOTATION

Preparation and application of magnesium oxide nanoparticles for superiorly fluoride removal

Preparation of High-Purity Ultrafine Magnesium Hydroxide Using Solid-State Reaction Method

Floc formation and growth mechanism during magnesium hydroxide and polyacrylamide coagulation process for reactive orange removal

Study on the Recovery of Flake Magnesium Hydroxide from Brine Sludge in Soda Industry

Preparation of magnesium hydroxide by ammonia gas method

Research and Application of Gangue for the Preparation of Polymerized Aluminum Magnesium Chloride Flocculant

Synthesis and characterization of MgSO4·5Mg(OH)2·2H2O flake powders

EFFECTIVENESS OF THE SEPARATION OF MAGNESIUM AND LITHIUM FROM SEAWATER WITH SODIUM SILICATE PRECIPITATION PROCESS

The Effect of pH and Sodium Silicate Dosage on the Separation of Magnesium and Lithium from Artificial Brine Water Using Chemical Precipitation Techniques

Research on Resourceful Disposal of Organosilicon Wastewater Containing Magnesium

Research Progress and Application of Magnesium Hydroxide Slurry

Study on the Flocculation Process of Mg(OH)2 Particles

The Separation Behavior of Impurities in the Purification of High-Purity Magnesium via Vacuum Distillation

Efficient preparation of magnesium bicarbonate from magnesium sulfate solution and saponification-extraction for rare earth separation

Flotation separation of magnesite and dolomite regulated by synergistic effect of acid etching and inhibitors

The Influence of Processing Conditions for the Preparation of Super-fine Hydroxide Magnesium by Hydrating Method

Study on the Recovery of Magnesium Sulfate Heptahydrate from Brine Sludge Produced in Soda Industry

Study on Preparation of Polysilicate Chloride Aluminum and Ferric Flocculant with Fly Ash