Abstract:It is inevitable for the occurrence or built-ups of disturbing cations, especially Ca 2+ or Mg 2+ ions, in process water during the flotation of iron oxides by using starch as flocculants. In addition to alkali concentrations and temperature, water quality could have an essential role in changing the physicochemical properties of the starch solution and consequently disturbing its flocculation performance on particles. This study aims to identify the effects of magnesium ions on the gelatinization characteristics of starch and its flocculation properties on particles through a series of tests, such as flotation tests, settling tests, size analyses, zeta potentials, powder contact angle, Fourier Transform Infra-Red (FTIR) and X-ray Photoelectron Spectroscopy (XPS) measurement. All results show that magnesium ions at ≤ 4 mmol/L have a positive role due to enlarging the sizes of the particle flocs and accelerating their settling rates. The occurrence of Mg 2+ ions at higher concentrations during starch gelatinization only obtains a starch sol-gel with entangled configurations and preoccupied active sites, resulting in the slower settling rate of the particle flocs and less hydrophilicity on mineral surfaces. It could be attributed to the cross-link interactions of magnesium-based precipitates with the acidic groups, especially carboxyl groups on the starch remnants. The suitable acid/base interactions between Mg(OH) 2 /MgCO 3 compounds with these groups in the starch suspension could be beneficial for enhancing the flocculation of hematite as they could build bridges among the pieces and enlarge their sizes as a “load carrier” for aggregation with minerals. However, too much cross-linking could re-entangle the remnants, block their adsorption sites on mineral surfaces, and eventually, weaken the flocculation capacity of starch.

Study on the Flocculation Process of Mg(OH)2 Particles

Effect of nitrate or sulfate on flocculation properties of cationic polymer flocculants

Agglomeration and Precipitation of Mg(OH)2 Particles in the Presence of Polyacrylamide

Original Data and Descriptions from Inhibition Mechanism of Ca2+, Mg2+ and Fe3+ in Fine Cassiterite Flotation Using Octanohydroxamic Acid

Development of an effective flocculation method by utilizing the auto-flocculation capability of Phaeodactylum tricornutum

Influences of magnesium ions in water on gelatinization characteristics of starch and its flocculation behaviors on particles

Study on Leaching at the Early Stage of Highly Efficient Flocculants

Analysis of particles size distributions in Mg(OH)2 precipitation from highly concentrated MgCl2 solutions

Magnesium hydroxide coagulation performance and floc properties in treating kaolin suspension under high pH

Inhibition Mechanism of Ca2+, Mg2+ and Fe3+ in Fine Cassiterite Flotation Using Octanohydroxamic Acid

Characterization of the Flocculation Process from the Evolution of Particle Size Distributions

Preparation of highly-dispersed Mg(OH)2 powders and influence factors

Effect of Electrolytes on Interactions Between a Novel Organic-Inorganic Hybrid Polymer Flocculant and Kaolinite Particles

Effect of intercalation of flocculant on adsorption properties of ZnMgAl-LDHs

Influence of synthesis condition on magnesium hydroxide properties by two-step reaction on pilot scale

PARAMETER EFFECTS ON PREPARATION OF NANOSIZED PARTICLES OF MAGNESIUM HYDROXIDE FROM DOLOMITE AND THEIR CHARACTERS

Additives Applied for Preparation of Superfine Mg(Oh)(2) Particles by Light-Burned Mgo at Low Temperature

Floc formation and growth mechanism during magnesium hydroxide and polyacrylamide coagulation process for reactive orange removal

Synthesis and characterization of MgSO4·5Mg(OH)2·2H2O flake powders

Flocculation of Both Kaolin and Hematite Suspensions Using the Starch-Based Flocculants and Their Floc Properties

Flocculation and dewatering of the Kaolin slurry treated by single- and dual-polymer flocculants