Abstract:Diamond-like carbon (DLC) films have been deposited on Si(100) substrates by an ion beam assisted deposition (IBAD) system. The effect of ion bombardment energy on surface roughness, mechanical and tribological properties of the DLC films has been studied over the ion bombardment energy range of 100-800 eV. The measured results of atomic force microscopy (AFM) showed that the DLC films are very smooth and the surface roughness is lower than that of the Si substrate at certain ion bombardment energy. Elasticity and nanohardness of the DLC films were studied by a nanoindentation technique. From nanoindentation load-displacement curves, it was concluded that most of the DLC films have high elasticity. Comparing the nanohardness with the conventional knoop microhardness of the same series of samples, we saw that the values of knoop microhardness are much higher than those of nanohardness. The correlation of the sp(3) bond fraction in the films estimated from Raman spectroscopy with surface roughness, elasticity and hardness has been established. Tribological behavior of the DLC films sliding against the ZrO2 ball was evaluated using a pin-on-disk tribometer. It was found that the surface roughness and the hardness have an effect on the friction coefficients. (C) 2000 Published by Elsevier Science S.A. All rights reserved.

Properties of DLC Films Produced by Pulsed Laser Induced Arc Deposition

Preparation of Anti-Reflective and Protective Diamond-Like Carbon Film on Si Substrate by Femto-Second Pulsed Laser Deposition

Tribological Properties of Diamond-Like Carbon Films Deposited by Pulsed Laser Arc Deposition

Deposition of nano-diamond-like carbon films by an atmospheric pressure plasma gun and diagnostic by optical emission spectrum on the process

Preparation and Tribological Properties of DLC/Ti Film by Pulsed Laser Arc Deposition

Diamond-like Carbon Film on 20 CrNiMo Steel Prepared by Hollow-Cathode Glow Discharge

Diamond-like Carbon Films Deposited by Femtosecond Laser Pulses

Mechanical and Tribological Properties of Diamond-Like Carbon Films Deposited by Electron Cyclotron Resonance Microwave Plasma Chemical Vapor Deposition

Diamond-like Carbon Film Synthesized by Ion Beam Assisted Deposition and Its Tribological Properties

Mechanical and tribological properties of non-hydrogenated DLC films synthesized by IBAD

Electronic-Properties of Semiconducting Diamond-Like Carbon Diamond

Diamond-Like Carbon Thin Films Deposited On Ti6al4v Alloy Surface By Plasma Gun At Atmospheric Pressure

Structure and Optical Characteristics of DLC Films

Deposition of DLC Film on Stainless Steel Substrates Coated by Nickel Using PECVD Method

Pulsed-laser deposition of diamond-like carbon: Relations between laser fluence, velocity of carbon ions, and bonding in the films

Fatigue and Frictional Behavior of Diamond-like Carbon Films Deposited by Filtered Cathodic Vacuum Arc Technique

Field Emission Properties of Diamondlike Carbon Films Deposited by Ion Beam Assisted Deposition

Electrodeposition Of Diamond-Like Amorphous Carbon Films On Si From N,N-Dimethylformamide

Studies of diamond-like carbon films coated on PMMA by ion beam assisted deposition

Studies of Diamond-Like Carbon Films Prepared by Ion Beam-Assisted Deposition

Structure and Topographies of Diamond-Like Carbon Films Produced on Tungsten Pre-Implanted Stainless Steel Substrate by Plasma Immersion Ion Implantation and Deposition