Abstract:The segregation behaviors of fine coal particles in a coal beneficiation fluidized bed (CBFB) were investigated in this work. The size range of 1–8mm was taken into account and three separate size fractions were studied comparatively in the experiments, e.g. 1–2mm, 3–5.5mm and 5.5–8mm. Both a clean coal sample and a gangue sample were used as the processed material to study the segregation behaviors of both light particles and heavy particles. The dense bed was divided as seven layers from bottom to top and the particle distribution in each layer for each sample was fully demonstrated. The influences of the particle density, particle size and the fluidized air velocity were revealed, the segregation patterns under different conditions were compared and the segregation mechanism was carefully analyzed. The results showed that the flotation and sedimentation of the particles in CBFB were still largely influenced by the particle density for the fine size range particles, and density stratification occurred even within each size fraction sample. The weight fraction in each layer showed a quadratic increase along the bed height for the coal particles. For gangue particles, a large fraction deposited in the bottom while the mass proportions in the middle layers also showed an increased tendency. With a decrease of the particle size, both the particle segregation and the density stratification phenomena deteriorated seriously. It was proved that particle feed size should be above 3mm as the separation effect was quite inefficient for finer particles. By increasing the fluidized air velocity, the bed density slightly decreased but the bed turbulence was largely strengthened by the increasing bubble boiling effect. The flotation and sedimentation of the particles in 5.5–8mm were obviously affected while no clear influence occurred to the rest of the two size fractions. Moreover, the results in this work provide a group of data that are quite suitable for CBFB numerical modeling studies.

Modeling of solids segregation in circulating fluidized bed boilers

Model on Single Density Solids Segregation in CFB Boiler

A Numerical Investigation on Segregation in Gas-Fluidized Beds of Short, Flexible Fibers

The Exit Impact on Segregation of Binary Particles in the CFB System

12th International Conference on Fluidized Bed Technology MODELING STUDY ON NON-UNIFORM DISTRIBUTION IN THE LATERAL DIRECTION IN LARGE SCALE CFB BOILERS

Numerical Study of Particle Segregation in a Coal Beneficiation Fluidized Bed by a TFM–DEM Hybrid Model: Influence of Coal Particle Size and Density

Modeling Study on Non‐Uniform Lateral Distribution in Large‐Scale Circulating Fluidized Bed Boilers

The segregation behaviors of fine coal particles in a coal beneficiation fluidized bed

Computational fluid study of radial and axial segregation characteristics in a dual fluidized bed reactor system

Numerical Study of the Effect of Operation Parameters on Particle Segregation in a Coal Beneficiation Fluidized Bed by a TFM–DEM Hybrid Model

Modeling of the axial distributions of volatile species in a circulating fluidized bed boiler

Particle Population Balance Model for a Circulating Fluidized Bed Boiler

Model Research On Material Balance In A Circulating Fluidized Bed Boiler

1D modeling on the material balance in CFB boiler

Numerical simulation of local and global mixing/segregation characteristics in a gas–solid fluidized bed

Study on the contamination coefficient of convective heating surface in a circulating fluidized bed boiler

Experimental Study of the Effect of Fluidization Velocity on the Segregation of Two Size Particles System

Density Distribution in the Furnace in 75 T/h CFB Boiler with Water Cooled Square Separator

Combustion Modeling Of Cfb Boiler Furnace Based On An Euler-Euler Approach

Size Segregation of Binary Mixture of Solids in Bubbling Fluidized Beds

Dynamic Model Establishment and Analysis on Gas-solid Flow in CFB Whole Loop