Abstract:High-performance polysilicon (P-Si) is fundamental as a resource for manufacturing semiconductor devices with high photoelectric properties. However, experimentally characterizing the solidification process in detail has been difficult on account of the extremely rapid cooling rate and limited available characterization methods. Therefore, this study used molecular dynamics (MD) to investigate Si crystallization behavior through directional solidification at different cooling rates. The entire system was first analyzed in terms of energy and radial distribution function, after which the microstructural evolution was characterized by visualization. Results indicated that the cooling rate significantly affected the directional solidification of Si, and an excessively high cooling rate resulted in a decrease in the long-range order of the system. At the same cooling rate, the crystallization rates of (1 0 0), (1 1 0), and (1 1 1) crystal faces followed a descending order. The configurations of the S-L interface with different crystal faces were distinct. Specifically, while the atom numbers of defect structures that were formed in systems of (1 0 0) and (1 1 0) crystal faces were few, those formed in the (1 1 1) crystal face were more. It was difficult for the (1 0 0) crystal face to form dislocations regardless of the crystallization degree at different cooling rates, and the (1 1 0) crystal face only formed a few dislocations at high cooling rates. Dislocations formed at all cooling rates during the directional solidification of the (1 1 1) crystal face, and there was a weak correlation between the number of dislocations and cooling rates. Twinning mainly occurred during the solidification process of the (1 1 1) crystal face, and there was no obvious linear relation between its number and the cooling rate. Moreover, when high-energy dislocations occurred more often, the system stability decreased. Overall, this work will be helpful to understand the commonness and difference in directional solidification of Si with different crystal faces at different cooling rates.

Low Amplitude Cyclic Deformation Behavior of Single Crystalline Silicon

Atomistic Investigations of Single-Crystal Silicon with Pre-Existing Defects

In Situ Tem Study of Deformation-Induced Crystalline-To-Amorphous Transition in Silicon

Deformations of Single-Crystal Silicon Circular Plate: Theory and Experiment

Influence of Strain Amplitude on Low-Cycle Fatigue Behaviors of a Fourth-Generation Ni-Based Single-Crystal Superalloy at 980 °C

Dynamic Deformation and Fracture of Single Crystal Silicon: Fracture Modes, Damage Laws, and Anisotropy

Critical Loading Conditions of Amorphization, Phase Transformation, and Dilation Cracking in 6h‐silicon Carbide

Cracking Study on the Flexible Circuits under Uniaxial Tensile Strain

Anomalous tension–compression asymmetry in amorphous silicon: insights from atomistic simulations and elastoplastic constitutive modeling

Reveal the Deformation Mechanism of (110) Silicon from Cryogenic Temperature to Elevated Temperature by Molecular Dynamics Simulation

The origin of fatigue fracture in single-crystal silicon

Micro-Raman Stress Characterization of Crystalline Si as a Function of the Lithiation State

An Analytical Solution for Inhomogeneous Strain Within Cylinders of Silicon and Effect on Quantum Band Structure under the Double-Punch Test

Molecular dynamics study of tensile-compressive behavior of silicon steel single crystal

Stress Relaxation Behaviors of Monocrystalline Silicon Coated with Amorphous SiO _2 Film: A Molecular Dynamics Study

Coarse-grained simulations of single-crystal silicon

Analysis of Structural Development and Defects during the Anisotropic Growth of Silicon

Stress effects on the Raman spectrum of an amorphous material: Theory and experiment on a -Si:H

Eliciting stable nanoscale fracture in single-crystal silicon

Experimental Analyses on Multiscale Structural and Mechanical Properties of Ε-Si/gesi/c-si Materials

Mechanical Properties and Deformation Behaviors of Surface-Modified Silicon: a Molecular Dynamics Study