Abstract:This study aims to investigate the role of hydrogen on CNTs synthesis and kinetics of CNTs formation. The CNTs were synthesized by catalytic chemical vapor deposition of methane over FeMo/MgO catalyst. The experimental results revealed that hydrogen plays an important role in the structural changes of catalyst during the pre-reduction process. The catalyst structure fully transformed into metallic FeMo phases, resulting in an increased yield of 5 folds higher than those of the non-reduced catalyst. However, the slightly larger diameter and lower crystallinity ratio of CNTs was obtained. The hydrogen co-feeding during the synthesis can slightly increase the CNTs yield. After achieving the optimum amount of hydrogen addition, further increase in hydrogen would inhibit the methane decomposition, resulting in lower product yield. The hydrogenation of carbon to methane was proceeded in hydrogen co-feed process. However, the hydrogenation was non-selective to allotropes of carbon. Therefore, the addition of hydrogen would not benefit neither maintaining the catalyst stability nor improving the crystallinity of the CNT products. The kinetic model of CNTs formation, derived from the two types of active site of dissociative adsorption of methane, corresponded well to the experimental results. The rate of CNTs formation greatly increases with the partial pressure of methane but decreases when saturation is exceeded. The activation energy was found to be 13.22 kJ mol −1 , showing the rate controlling step to be in the process of mass transfer.

Effect of Temperature, Pressure, and Gas Ratio of Methane to Hydrogen on the Synthesis of Double-Walled Carbon Nanotubes by Chemical Vapour Deposition

Dimethyl Terephthalate Hydrogenation to Dimethyl Cyclohexanedicarboxylates over Bimetallic Catalysts on Carbon Nanotubes

The confined growth of double-walled carbon nanotubes in porous catalysts by chemical vapor deposition

The influence of different atmosphere gases on the growth and structure of double-walled carbon nanotubes

Effects of methane partial pressure on synthesis of single-walled carbon nanotubes by chemical vapor deposition

Effect And Mechanism Of Water On Carbon Nanotubes Growth

Synthesis of MWCNTs by chemical vapor deposition of methane using FeMo/MgO catalyst: role of hydrogen and kinetic study

The effect of phase separation in Fe/Mg/Al/O catalysts on the synthesis of DWCNTs from methane

The Effect of Hydrogen on the Formation of Nitrogen-Doped Carbon Nanotubes Via Catalytic Pyrolysis of Acetonitrile

Temperature Selective Growth Of Carbon Nanotubes By Chemical Vapor Deposition

Synthesis Of High Quality Single-Walled Carbon Nanotubes By Cvd And Effect Of Catalyst'S Acidity-Basicity On Nanotubes Growth

Effect of Hydrocarbons Precursors on the Formation of Carbon Nanotubes in Chemical Vapor Deposition

Catalytic Chemical Vapor Deposition of Methane to Carbon Nanotubes: Copper Promoted Effect of Ni/MgO Catalysts

Synthesis of Single-Walled Carbon Nanotubes by Chemical Vapor Deposition of Methane in A Fluidized Bed Reactor: Temperature and Reaction Time Effects

Effect of Carrier Gas on Quality of Cvd Synthesized Carbon Nano-Materials over High Performance Co/Mgmoo4 Catalyst

A New Method for Synthesizing Double-Walled Carbon Nanotubes

Effect of the reaction atmosphere on the diameter of single-walled carbon nanotubes produced by chemical vapor deposition

Controllable growth of double wall carbon nanotubes in a floating catalytic system

Catalytic Vapor Decomposition of Methane over Nickle Catalyst: Growth Rate and the Corresponding Microstructures of Carbon Nanofibers

Effects of hydrogen on the formation of aligned carbon nanotubes by chemical vapor deposition

Preparation of Double-Walled Carbon Nanotubes