Abstract:The development of 5G technology has put forward new requirements for computing the abilities of chips, and chip power has also significantly increased. Consequently, the heat load of the rack will increase rapidly in the future. Traditional computer room air conditioning (CRAC) systems cannot satisfy the rack's high heat flux dissipation requirements, and new cooling forms such as chip-level cooling should be adopted. In this study, a two-stage chip-level cooling system, which is pumpless and waterless, offers flexible and detachable installation based on practical requirements, was proposed. The cooling system removes heat from the chips to the outdoors via two thermosiphon loops, where the heat is first transferred to cold plates tightly attached to the chip surfaces, then transferred through heat exchangers attached to the rack side, and finally dissipated outdoors through air cooling. In this study, a two-stage chip-cooling system was constructed and tested in an enthalpy-difference laboratory. The effects of the liquid filling ratio on the thermal resistance, total temperature difference, and fluid flow pattern under different heat loads were investigated. Second, a heat transfer model for analysing thermal resistance networks was constructed, and the proportions of different types of thermal resistance were determined. Third, an energy-saving analysis of the system is established. The experimental results showed that at single chip heat load 200 W and total heat load 2 kW, the heat transfer temperature difference between chips and outdoors is less than 20 degrees C at extremely high energy efficiency (cooling load factor reaches 0.05 at outdoor temperature 40 degrees C), which makes it feasible for free cooling throughout the year in most Chinese areas. The annual PUE in Beijing using the proposed system is 1.15, which indicates a 30 % reduction of the total energy consumption of data centres.

Sub-Cooler for Air Conditioner Based on Thermoelectric Effect of Semiconductor

Investigations on Coupling Between Performance and External Operational Conditions for a Semiconductor Refrigeration System

Study on the Performance of a Solid-State Thermoelectric Refrigeration System Equipped with Ionic Wind Fans for Ultra-Quiet Operation

Design Optimization of Thermoelectric Cooling Systems for Applications in Electronic Devices

Heat Sinking Problem in Air-Cooled Semiconductive Air-Conditioning

Thermodynamic Analysis and Experimental Research of Water-Cooled Small Space Thermoelectric Air-Conditioner

Performance Research of a Semiconductor Cooling Device with Solid Desiccant

Coolers Based on Semiconductor Refrigeration Technology for Electric Vehicle On-Board Chargers

Experimental research on a semiconductor freezer utilizing two-stage thermoelectric modules

Performance simulation of CO2 transcritical cooling system with mechanical subcooling cycle for automobile air conditioning

Simulation and Experimental Study of CO2 Transcritical Heat Pump System with Thermoelectric Subcooling

Experimental and numerical investigation on thermoelectric coolers for comparing air-to-water to air-to-air refrigerators

Experimental investigation on water-cooled thermoelectric air conditioner driven by solar cells

Performance Study of Portable Semiconductor Refrigeration Device Based on CFD Simulation

Development and Investigation of Air-Cooled Thermoelectric Air-Conditioner

Efficient Thermoelectric Cooler for Localized Cooling in Electronic Devices

Design and Optimization of Thermoelectric Cooling System under Natural Convection Condition

Experimental Research and Energy Effectiveness Analysis on Chip-Level Two-Stage Loop Thermosyphon System for Data Centre Free Cooling

Thermodynamic Analysis on Sub-cooling Process in CO_2 Trans-critical Refrigeration Cycle

Experimental Investigation On Thermoelectric Air Conditioner Driven By Solar Cells

A Solar-Assisted Hybrid Air-Cooled Adiabatic Absorption and Vapor Compression Air Conditioning System