Abstract:In this article, we present an experimental study on the impact of post-metallization annealing conditions on the negative-bias temperature instability (NBTI) of Si p-channel fin field-effect transistors (p-FinFETs) with atomic layer deposition tungsten (ALD W) as the gate-filling metal. The effects of annealing conditions on the tensile stress of the W film, impurity element concentration in the gate stack, fresh interface quality, threshold voltage shift ( ${\Delta }$ V $_{T}$ ), pre-existing traps ( ${\Delta } {N} _{\mathrm {HT}}$ ), generated traps, and their relative contributions were studied. The time exponents of ${\Delta }$ V $_{T}$ , the impacts of stress bias and temperature on NBTI degradation, and the recovery kinetics of the generated traps were analyzed. For devices with a B2H6-based W-filling metal, a 34% reduction in the fresh interface states, reduced ${\Delta }$ V $_{T}$ , and a 29% improvement in the operation overdrive voltage could be achieved by optimizing the annealing conditions. The NBTI is alleviated mainly because of the reduction in the generated traps, while the energy distribution of ${\Delta } {N} _{\mathrm {HT}}$ is insensitive to the annealing conditions. Furthermore, the relative contribution of the generated bulk insulator traps to the total number of generated traps could be reduced by optimizing the annealing conditions.

Effects of low-temperature water vapor annealing of strained SiGe surface-channel pMOSFETs with high-κ dielectric

Use of water vapor for suppressing the growth of unstable low-κ interlayer in HfTiO gate-dielectric Ge metal-oxide-semiconductor capacitors with sub-nanometer capacitance equivalent thickness

Modulation of Interfacial and Electrical Properties of ALD-derived HfAlO/Al2O3/Si Gate Stack by Annealing Temperature

Effects of Ti content and wet-N2 anneal on Ge MOS capacitors with HfTiO gate dielectric

Effects of Annealing Gas on Electrical Properties and Reliability of Ge MOS Capacitors with HfTiON As Gate Dielectric

Low-frequency noise and Coulomb scattering in Si0.8Ge0.2 surface channel pMOSFETs with ALD Al2O3 gate dielectrics

Low-temperature Annealing of Polycrystalline Si/sub 1-X/ge/sub X/ after Dopant Implantation

Influence of Surface Treatment Prior to ALD High-/Spl Kappa/ Dielectrics on the Performance of SiGe Surface-Channel Pmosfets

Thermal Annealing Effects on a Compositionally Graded SiGe Layer Fabricated by Oxidizing a Strained SiGe Layer

Thermal Annealing Effects on the Structure and Electrical Properties of Al2O3 Gate Dielectrics on Fully Depleted SiGe on Insulator

Reliability Improvement of Ge Pmosfets with Al2O3 Dielectric by Ozone Post Annealing

Interface Optimization and Performance Enhancement of Er2O3-Based MOS Devices by ALD-Derived Al2O3 Passivation Layers and Annealing Treatment

Effect of annealing on interfacial and band alignment characteristics of HfO 2/SiO 2 gate stacks on Ge substrates

Annealing Process on MOS channel Properties for Quasi‐Vertical GaN‐on‐Sapphire Trench MOSFET

Alleviation of Negative-Bias Temperature Instability in Si P-Finfets with ALD W Gate-Filling Metal by Annealing Process Optimization

Growth and Characterization of Al2o3 Gate Dielectric Films by Low-Pressure Metalorganic Chemical Vapor Deposition

Effect of Temperature-Dependent Low Oxygen Partial Pressure Annealing on SiC MOS

Improved SOI FinFETs Performance With Low-Temperature Deuterium Annealing

Channel Surface Integrity with 2.4nm High-k Gate Dielectric under DPN Treatment at Different Annealing Temperatures

Low temperature atomic hydrogen annealing of InGaAs MOSFETs

Low-Temperature Deuterium Annealing for HfO2/SiO2 Gate Dielectric in Silicon MOSFETs