Abstract:During operation, converter transformers enter a saturation state, leading to phenomena such as magnetising inrush currents. Accurately measuring the excitation characteristic curve of an iron core under deep-saturation conditions is essential for analysing low-frequency transient phenomena in transformers. This paper presents a method for calculating the excitation characteristics of a converter transformer under deep iron core saturation. The method involves establishing an improved T model for the converter transformer and conducting open-circuit experiments in the linear working region to obtain the excitation characteristic curve and knee point parameters. AC-DC hybrid excitation is used to achieve deep saturation, and measurements of saturated inductance at different levels of saturation at the transformer terminals are taken. The mathematical relationship between saturated inductance and magnetic impedance is derived, allowing deduction of the magnetising characteristic curve of the converter transformer under deep-saturation conditions based on measured saturated inductance values. A finite element simulation analysis was performed on a single-phase four-column converter transformer with a capacity of 250 MVA. Additionally, a test platform for toroidal transformers and dry-type transformers has been set up to carry out excitation characteristic measurement and verification. Experimental results demonstrate that errors are maintained within 10% or less, validating this approach's effectiveness.

Application Study on the Saturable Magnetic Circuit Method to Measuring the DC Resistance of Transformer’s Winding

Research on the Practicality of Current Transformer Saturation Detection Using the Magnetic Restraint Principle

Fast and Effective DC Resistance Measurement Method for Large Transformer Winding

The Numerical Simulation Method of Transformer Internal Short-Circuit Fault

On-line Demagnetization Method for an Iron Core CT

MAGNETIC RESTRAINING DIFFERENTIAL BUS PROTECT

Measurement Method of Deeply Saturated Excitation Characteristics of Converter Transformer Under AC-DC Hybrid Excitation

Torque Analytical Model of Switched Reluctance Motor Considering Magnetic Saturation

THE INFLUENCE OF CURRENT TRANSFORMER SATURATION ON BUS PROTECTION

A Novel Method for Current Transformer Saturation Countermeasure Based on Comparing Two Currents' Polarities

Study of the Heavy Direct Current Indirect Measurement and Calculation Based on the Waveform Measuring of Valve Currents

An Experimental Study of the Sweep Frequency Impedance Method on the Winding Deformation of an Onsite Power Transformer

Detection Method for Current Transformer Saturation Based on the Dropping of the Secondary Current

Study of Current Measurement Method Based on Circular Magnetic Field Sensing Array

Research on Identification of Partial Transient Saturation in Currant Transformers

In-Situ Measurement and Investigation of Winding Loss in High-Frequency Cored Transformers Under Large-Signal Condition

An Application Study of a New De-Excitation Method for Generator with Self-Shunt Excitation

Dynamic Modeling of Surface-Mounted Permanent Magnet Motors Considering Saturation

Steady-state Analysis of Internal Short Circuits of Multi-winding Power Transformer Part Ⅱ Experiment Verification and Sensitivity Analysis of Differential Relay Protection

A Review of Research Progress on Residual Magnetism Detection Methods for Power Transformer Cores

Magnetic state balance technology of transformer based on magnetic field modulation strategy