Abstract:Room-temperature deep Si etching using time-multiplexed deep reactive ion etching (DRIE) processes is investigated to fabricate ultra-high aspect ratio Si nanowires (SiNWs) perpendicular to the silicon substrate. Nanopatterning is achieved using either top-down techniques (e.g. electron beam lithography) or colloidal polystyrene (PS) sphere self-assembly. The latter is a faster and more economical method if imperfections in diameter and position can be tolerated. We demonstrate wire radii from below 100 nm to several micrometers, and aspect ratios (ARs) above 100:1 with etching rates above 1 μm min(-1) using classical mass flow controllers with pulsing rise times of seconds. The mechanical stability of these nanowires is studied theoretically and experimentally against adhesion and capillary forces. It is shown that above ARs of the order of 50:1 for spacing 1 μm, SiNWs tend to bend due to adhesion forces between them. Such large adhesion forces are due to the high surface energy of silicon. Wetting the SiNWs with water and drying also gives rise to capillary forces. We find that capillary forces may be less important for SiNW collapse/bending compared to adhesion forces of dry SiNWs, contrary to what is observed for polymeric nanowires/nanopillars which have a much lower surface energy compared to silicon. Finally we show that SiNW arrays have oleophobic and superoleophobic properties, i.e. they exhibit excellent anti-wetting properties for a wide range of liquids and oils due to the re-entrant profile produced by the DRIE process and the well-designed spacing.

Conductive-probe Atomic Force Microscopy Characterization of Silicon Nanowire

Silicon Nanowires, Catalytic Growth and Electrical Characterization

Array-orderly single crystalline silicon nano-wires

Synthesis and Raman Spectra of Si-Nanowires

J212015 Quantitative Evaluation of Conductivity of Metallic Nanowires by Microwave Atomic Force Microscopy

Silicon Nano-Wires Fabricated by Thermal Evaporation of Silicon Wafer

Fabrication of Straight Silicon Nanowires and Their Conductive Properties

Tiny silicon nano-wires synthesis on silicon wafers

Non-destructive characterization of silicon nanowires and nanowire coatings using mid-infrared spectroscopy

Ultra-low dissipation patterned silicon nanowire arrays for scanning probe microscopy

OS1503 Development of Highly Ordered Silicon Nanowire Array

Ph Response of Silicon Nanowire Sensors: Impact of Nanowire Width and Gate Oxide

NOVEL AFM PROBE FOR LOCAL CONDUCTIVITY MEASUREMENT

Surface Defects-Induced P-Type Conduction of Silicon Nanowires

High density germanium nanowire assemblies: contact challenges and electrical characterization

Growth-In-Place Deployment of In-Plane Silicon Nanowires

Photoelectrical Properties Investigated on Individual Si Nanowires and Their Size Dependence

Dispersion, Refinement, and Manipulation of Single Silicon Nanowires

TEM Investigation of Asymmetric Deposition-Driven Crystalline-to-Amorphous Transition in Silicon Nanowires

Ultra-high aspect ratio Si nanowires fabricated with plasma etching: plasma processing, mechanical stability analysis against adhesion and capillary forces and oleophobicity

P-N Crossed Nanojunctions from Electroless-Etched Si Nanowires