Abstract:The stabilization of isotropic pitch (IP)-derived pitch fibers (PFs) and mesophase pitch (MP)-derived PFsin air was performed at different heating rates and with different final stabilization temperatures. The stabilized fibers (SFs) and carbon fibers (CFs) were characterized by elemental analysis, FT-IR, TG-MS and SEM to investigate the influence of the degree of oxidation of the SFs on the microstructures and mechanical properties of the CFs. Results showed that a slow heating rate during stabilization was beneficial to the oxidative cross-linking of PFs, and the corresponding CFs had a higher carbonization yield and tensile strength at the lower heating rate. When both IPF and MPF were stabilized at 270 oC, the two resulting CFs all reached their optimal performance. In addition, the FTIR peak intensity ratio of the C=O band at about 1700 cm–1 to the C=C band at 1600 cm–1 of the SFs had a good relationship to the carbonization yield and tensile strength of the CFs, and thiscan beusedto optimize the degree of oxidation of the SFs. Moreover, insufficiently stabilized fibers released a great deal of H2 and CH4, causing some porosity in the resulting CFs with a low tensile strength, especially forthe insufficiently stabilized IPCF. While over-stabilized fibers released a large amount of CO and CO2, causing cracked textures in the corresponding CFs, especially inthe over-stabilizedMPCF. Therefore, this research into the stabilization and carbonization behaviors of pitch fibers has great significance for improving the mechanical properties of pitch-based CFs.

Pitch Spheres Stabilized by HNO3 Oxidation and Their Carbonization Behavior

Effect of Preoxidation with HNO3 and Air on Preparation of Pitch-Based Spherical Activated Carbon

Oxidative stabilization of pitch spheres in fluidized bed and their carbonization behavior

An Investigation of the Preparation of Coal Tar- and Petroleum-Based Pitch Spheres and Their Oxidation Stabilization

STUDY ON THE OXIDATIVE STABILIZATION OF PITCH SPHERES

Evaluating of the oxidative behaviors of isotropic pitch fractions for optimal the mechanical properties of isotropic pitch-based carbon fibers

INFLUENCE OF SOLVENT IMMERSION ON THE OXIDATIVE STABILIZATION OF PITCH SPHERES

Preparation and characterization of pitch coke from oxidized polymerized pitch

Promoter action of sulphur on the stabilization of pitch spheres

Catalytic Oxidation of NO at Room Temperature by Pitch-Based Activated Carbon Fibers

Effects of the degree of oxidation of pitch fibers on their stabilization and carbonization behaviors

Modification of Coal Tar Pitch with Aromatic Nitro-Compounds

Preparation of Pitch-based Activated Carbon Fibers and Their Catalytic Oxidation Performance for NO

Spinnable Mesophase Pitch Prepared via Co-carbonization of Fluid Catalytic Cracking Decant Oil and Synthetic Naphthalene Pitch

CHEMICAL STRUCTURE AND CARBONIZATION BEHAVIORS OF AIR-BLOWN PITCHES

Preparation of pitch-based carbon materials by pyrolysis and their electrocatalytic activity in oxygen reduction reaction

Study on the Preparation of Petroleum Pitch-Based Activated Carbon

Transformation of doped Fe in pitch sphere in carbonization and activation processes

The surface chemistry of pitch-based spherical activated carbon (PSAC) and the effect of gas-oxidation treatment on its adsorption performance

STUDY ON MECHANISM OF MESOPORE FORMATION OF PITCH-BASED SPHERICAL ACTIVATED CARBON USING IRON AS CATALYST

Influence of Oxygen Uptake on Pitch Carbon Fiber