Abstract:The introduction of aliphatic structure by co‐carbonization of coal tar pitch and atmospheric residual provides more methylene bridge bonds and more α‐hydrogens for spinnable pitch, which makes pitch molecular more linear and naphthenic. The α‐hydrogens of aliphatic structure of the CCA‐3 are easily attacked by oxygen, showing a higher oxidative stabilization efficiency. The obtained pitch‐based carbon fiber shows excellent mechanical properties. As a pivotal step in the preparation of carbon fiber, oxidative stabilization not only plays a crucial role in maintaining fibrous morphology but also contributes significantly to enhance mechanical properties of resultant carbon fiber. Due to high activation energy of pitch molecules reaction with oxygen and the sluggish diffusion of oxygen within the fiber, the improvement of oxidative stabilization efficiency faces significant challenges. Atmospheric residual (AR) has a high and easily oxidized aliphatic structure. Spinnable pitch is synthesized by co‐carbonization of coal tar pitch (CTP) and AR at a ratio of 3:1 in this work. Its methylene bridge bond ratio is 4.45% and have an appropriate amount aliphatic structure, which makes pitch molecular more linear and naphthenic. Excessive addition of AR is detrimental to spinning performance. The most optimal oxidative stabilization temperature of as‐spun fiber was 280°C, which is lower than that of fiber produced by CTP alone (300°C), displaying a higher oxidative stabilization efficiency. The obtained pitch‐based carbon fiber shows excellent mechanical properties with tensile strength of 999.0 ± 80.1 MPa and Young's modulus of 57.7 ± 3.5 GPa. The co‐carbonization by two different substances has been applied in manufacturing carbon fiber, providing a facile approach to accelerate the oxidative stabilization of pitch fiber.

INFLUENCE OF SOLVENT IMMERSION ON THE OXIDATIVE STABILIZATION OF PITCH SPHERES

Evaluating of the oxidative behaviors of isotropic pitch fractions for optimal the mechanical properties of isotropic pitch-based carbon fibers

Effects of the degree of oxidation of pitch fibers on their stabilization and carbonization behaviors

Investigation on promotion effect of oxidative stabilization for pitch‐based fiber by co‐carbonization of coal tar pitch and atmospheric residual

Preparation Process of Coal Tar Pitch Powder and Its Stability Research

Effect of petroleum-based coating pitch preparation on toluene insolubles generation

Modified effect on properties of mesophase pitch prepared from various two-stage thermotreatments of FCC decant oil

Preparation of Mesophase Pitch through Supercritical Fluid Extraction of Coal Tar Pitch

Preparation of pitch semi-coke water slurry and its properties of slurryability and gasification

Modification of Coal Tar Pitch with Aromatic Nitro-Compounds

Analyzing solid fossil-fuel pitches by a combination of Soxhlet extraction and Fourier transform ion cyclotron resonance mass spectrometry

Co‐Carbonization of Medium‐ and Low‐Temperature Coal Tar Pitch and Coal‐Based Hydrogenated Diesel Oil Prepare Mesophase Pitch for Needle Coke Precursor

Study on the Variety of Rheological Properties and Thermal Analysis of Modified Coal Tar Pitch with 1,4-Benzenedimethanol

Co-carbonization Behaviors of Petroleum Pitch/waste SBS: Influence on Morphology and Structure of Resultant Cokes

Study on the characterization and thermal conversion behavior of sequential extraction products from medium temperature coal pitch

Mesophase formation of coal-tar pitches used for impregnant of C/C composites

Influence of boron trifluoride complex addition on structure and composition of mesophase pitch from FCC decant oil via two-stage thermotreatment

Tuning the carbon morphology by pyrolysis in AlCl3–NaCl molten salt from coal tar pitch

Structure and composition of mesophase pitch prepared from aromatic‐rich fluid catalytic cracking slurry under different process conditions

Research on Coal Tar Pitch Catalytic Oxidation and Its Effect on the Emission of PAHs during Co-Carbonation with Coal

Purification of Quinoline Insolubles in Heavy Coal Tar and Preparation of Meso-Carbon Microbeads by Catalytic Polycondensation