Abstract:Soft coal tar pitch (SCTP) with low QI content is the preferred raw material for preparing coal-based needle coke, the study on its structure changes in the stage of liquid-phase carbonization into coke (350 similar to 550 degrees C) is helpful to prepare high-quality needle coke. In this paper, a detailed analysis on the C-H stretching vibration peaks in the range of 3 100 similar to 2 800 cm(-1) and the aromatic C-H bending vibration peaks in the range of 900 similar to 700 cm(-1) has been carried by the peak-fitting technique using the infrared spectra of the sample. And then based on the calibration factors of the corresponding C-H vibration peaks for the stand- ard substances, the mass percentages of the different types of aromatic hydrogen (H-solo , H-duo, H-trio and H-quarto) and aliphatic hydrogen (H-CH3, H-CH2 and H-CH) of SCTP were quantitated at different carbonization temperatures (400, 500, 600 and 800 degrees C). Furthermore, the contents of SP2 hybridized Carbon ((SPC)-C-2) and SP3 hybridized Carbon ((SPC)-C-3) as well as these structural parameters such as H/C atomic ratio, aromatic index (I-ar) , aromatic ortho-substitution index (I-os) and branched index (CH3/CH2) were calculated, and the changes of aromatic structure of SCTP during the coking process were also discussed. The results showed that the coal-based needle coke raw material SCTP is mainly composed of aromatic hydrocarbons with a low number of the ring and few side chains, its I(ar )is 0. 77, and about 82% of its aromatic hydrogen is distributed in the structure containing three/four adjacent aromatic C-H, while its aliphatic hydrogens are mainly distributed in the CH2 of naphthenic structures. With the increase of carbonization temperature, the aliphatic hydrogen or (SPC)-C-3 of SCTP decreased almost linearly, losing about 50% at 400 degrees C , which was mainly attributed to the loss of light components and the dehydrogenation of naphthenic structures. The green coke formed at 500 degrees C had Only 0. 15 Wt. % aliphatic hydrogen and 0. 88 Wt. % SP3 C, and the presence of aliphatic hydrogen was not detected at 600 degrees C. However, the aromatic hydrogen increased slightly from 3. 89 Wt. % of the raw material to 4. 5 Wt. % before 400 degrees C because of the conversion of the naphthenic structuresinto aromatic rings. As the temperature increases further, aromatic hydrogen decreases rapidly, reaching only 1. 14 Wt. % when the temperature reaches 500 degrees C , indicating that the aromatic hydrocarbon molecules undergo intense dehydrogenation condensation reaction during the mesophase formation stage at 400 similar to 500 degrees C , which was also confirmed by the conversion of a large number of protonated (SPC)-C-2 into unprotonated (SPC)-C-2. Aromatic hydrogen continued to decrease after 500 degrees C , and their presence was not detected at 800 degrees C. In addition, it was found that the out-of-planebending vibration of aromatic C-H is more sensitive to infrared light than its in-plane stretching vibration. The increase of I-ar and the decrease of these parameters such as H/C atomic ratio, I-os, CH3/CH2, indicated that the aromatic molecules in the SCTP are gradually grown up by their condensation, and its aromaticity increased in the coking process. The fast quantification of various types of hydrogen by infrared spectrum can timely understand the structural changes of aromatic hydrocarbon molecules of the pitch in the coking process, which is helpful to the production of needle coke.

Analyzing solid fossil-fuel pitches by a combination of Soxhlet extraction and Fourier transform ion cyclotron resonance mass spectrometry

Study on the characterization and thermal conversion behavior of sequential extraction products from medium temperature coal pitch

Preparation of Mesophase Pitch through Supercritical Fluid Extraction of Coal Tar Pitch

Insight into the Pyrolysis Behaviors of Petroleum-Driven Mesophase Pitch via ReaxFF Molecular Dynamics and In Situ TG-FTIR/MS

Evaluating of the oxidative behaviors of isotropic pitch fractions for optimal the mechanical properties of isotropic pitch-based carbon fibers

Co‐Carbonization of Medium‐ and Low‐Temperature Coal Tar Pitch and Coal‐Based Hydrogenated Diesel Oil Prepare Mesophase Pitch for Needle Coke Precursor

Molecular representation and atomic-level coking evolution investigation of modified coal tar pitch via 13 C NMR, MALDI-TOF-MS, SAXS, and ReaxFF MD

Synthesis and Structural Evolution of Coal-Based Mesophase Pitch by Hydrogenation-Vacuum Thermal Polycondensation Process

Extraction of Coal-Tar Pitch Using Nmp/Ils Mixed Solvents

Structure and composition of mesophase pitch prepared from aromatic‐rich fluid catalytic cracking slurry under different process conditions

Mesophase formation of coal-tar pitches used for impregnant of C/C composites

Effect of petroleum-based coating pitch preparation on toluene insolubles generation

Spinnable Mesophase Pitch Prepared via Co-carbonization of Fluid Catalytic Cracking Decant Oil and Synthetic Naphthalene Pitch

Differences and correlations between microstructure and macroscopic properties of mesophase cokes derived from the components of high temperature coal tar pitch

Analysis of the properties of two kinds of coal tar pitches used for impregnation of C/C composite

Comparison of the composition and structure for coal-derived and petroleum heavy subfraction by an improved separation method

Tuning the carbon morphology by pyrolysis in AlCl3–NaCl molten salt from coal tar pitch

Exploration of coal tar asphaltene molecules based on high resolution mass spectrometry and advanced extraction separation method

Infrared Spectroscopic Quantitative Analysis of Raw Material Used As Coal-Based Needle Coke in the Coking Process

Preparation of pitch precursor with excellent spinnability for general-purpose carbon fibre using coal tar pitch as raw material

Exploration of fibers produced from petroleum based-mesophase pitch and pet blends for carbon fiber production