Abstract:The valence states of copper-based catalyst are still controversial for whether Cu+ exists or even dominates the corresponding catalysis performance, especially for the catalyst prepared by unconventional method. For example, Cu/SiO2 catalyst prepared by deposition-precipitation exhibits different ratio of Cu-0 and Cu+ in the literatures. Zinc-doping Cu/SiO2 catalyst is primarily chosen for carbonyl hydrogenation. Additionally, the copper, catalysts employed in the industrial reactor require a doping of zinc for catalyst stability and relatively low temperature reduction, which makes they valence states of copper catalyst under working conditions even more complicated. In this paper, copper phyllosilicate, 15 w1% Cu-5.0 wt% Zn/SiO2, was prepared by ammonia evaporation method with the following procedures: (1) complexation of Cu/Zn to silicasol by mixing of an amount of copper ammonia solution (0.5 mol/L) and zinc ammonia solution (0.5 mol/L) with silicasol (5%, SiO2) for 5 h at room temperature, and then decomposition of metal ammonia under 95 degrees C; (2) dried, crushed and calcined at 450 degrees C for 4 h. The Cu/SiO2 catalyst precursor without the addition of zinc was prepared with the same procedures as Cu-Zn catalyst precursor. The valence states of copper catalyst of Cu-Zn/SiO2 and Cu/SiO2 catalyst during hydrogen reduction in the temperature range of 20 degrees C to 350 degrees C has been studied by in situ X-ray absorption spectroscopy characterization under the atmosphere of 10% H-2 in He, 50 mL/min. Valence state composition was analyzed by using Linear Combination Fitting (LCF) method based on X-ray Absorption Near Edge Spectroscopy (XANES) spectra, which indicated: (1) the reduction degree of Cu2+ to Cu-0 is increased with the addition of zinc; (2) Cu+ occurred and mainly existed at low reduction temperature (<250 degrees C) with a low concentration, but it diminished completely at high reduction temperature; (3) Cu-0 could be the active center for hydrogenation of methyl acetate to ethanol.

Xps Study on Cuznal Catalysts Prepared by Different Methods for Direct Synthesis of Dimethyl Ether

Effect of Composition of Raw Materials on Structure and Dimethyl Ether Synthesis Activity of Cu-Zn-Al Catalyst Prepared by Complete Liquid Phase Method

Complete liquid-phase preparation and characterization of Cu-Zn-Al-Zr slurry catalysts for synthesis of dimethyl ether

The Structure Properties of CuZnAl Slurry Catalysts Prepared by a Complete Liquid-Phase Method and its Catalytic Performance for DME Synthesis from Syngas

Effect of Si Content on the Performance of Direct Synthesis of Dimethyl Ether over Slurry CuZnAl Catalyst Prepared by Complete Liquid Phase Technology

Complete Liquid Phase Preparation and Characterization of CuZnAlSi Catalysts for DME Synthesis in Slurry Reactor

Catalytic performance of CuZnAl slurry catalyst prepared by complete liquid phase technology for direct synthesis DME from syngas

Kinetic Study of Complete Liquid-Phase Catalyst for Dimethyl Ether Synthesis

XPS Studies of Cu/ZnO/Al2O3 Ultra-Fine Catalysts Derived by a Novel Gel Oxalate Co-Precipitation for Methanol Synthesis by CO2+H2

Effect of Surfactant on Structure and Performance of Catalysts for DME Synthesis in Slurry Bed

Study on Catalyst C207-HZSM-5 for Dimethyl Ether Synthesis

Liquid-phase preparation of catalysts used in slurry reactors to synthesize dimethyl ether from syngas: Effect of heat-treatment atmosphere

Synergistic Effect of Zinc and Manganese in Cu-Mn-Zn/Y Catalyst for Syngas-to-dimethyl Ether

Effect of the Addition of Manganese and Zinc on the Properties of Copper-Based Catalyst for the Synthesis of Syngas to Dimethyl Ether

A NOVEL PREPARETION OF Cu-Mn CATALYSTS FOR DIMETHYL ETHER SYNTHESIS FROM SYNGAS

Single-step dimethyl ether synthesis on a Cu/ZnO/Al_2O_3/ZrO_2+γ-Al_2O_3 bifunctional catalyst in slurry reactor

An investigation into the effects of different existing states of aluminum isopropoxide on copper-based catalysts for direct synthesis of dimethyl ether from syngas

Investigation of the Structural Evolution and Catalytic Performance of the Cuznal Catalysts in the Hydrogenation of Dimethyl Oxalate to Ethylene Glycol

In Situ X-ray Absorption Spectroscopy Characterization of Copper Valence State in Cu-Zn/SiO2 Catalyst

Effect of copper content on Cu–Mn–Zn/zeolite-Y catalysts for the synthesis of dimethyl ether from syngas