Numerical Simulation of Cross Flow in Fixed Bed Reactor

LIU Yong-bing,CHEN Ji-zhong,YANG Yong-rong

DOI: https://doi.org/10.3321/j.issn:1003-9015.2006.04.006

2006-01-01

Abstract:Based on the Ergun’s equation and with considering the convection term and diffusion term of the fluid flow, a mathematic model used to simulate the fluid flow in the fixed-bed reactor with inner immersed tubes was established. Using the model developed, the pressure distribution of the fixed-bed reactor was calculated, and the calculating results have good agreement with the corresponding experimental data obtained from literature, which indicates that the model is reliable. Furthermore, the model was used to study the gas velocity distribution affected by the immersed tubes in the fixed-bed reactor. The results show that along the main gas flow direction, the gas velocity v close to the tube-wall descends remarkably at the front of and behind the tubes because of the hindrance of the tubes, however, the v increases between the tubes. The peak and width of the wavy gas velocity distribution curves along the width of the fixed-bed are relative to the space between the tubes, the inlet gas velocity and the tube arrangement mode. It is found that the hindrance effect of the tube on the gas velocity is only limited within a distance of the tube diameter measured from the center of the tube. It is also shown that the staggered arrangement of the tubes with triangular pitch will cause stronger disturbance of the gas flow than that caused by the in-line arrangement with square pitch, so that the former arrangement mode will favor to the heat transfer and will cause the temperature field to become more uniform in the fixed-bed reactor.