Abstract:Ternary atomic layer deposition of Sn-doped TiOx (Sn:TiOx) and Ti-doped SnOx (Ti:SnOx) was performed using tetrakisdimethylamidotitanium (IV) and tin(IV) with water at 150 °C on (1 0 0) Si and quartz substrates. The physical structure of the films was investigated using scanning electron, atomic force, and Kelvin probe force microscopies as well as spectroscopic ellipsometry, Raman spectroscopy, and X-ray diffraction. All as-deposited films are amorphous and possessed flat and conformal topographies with low surface roughness (<1 nm). Annealed Sn:TiOx and Ti:SnOx crystallize into the tetragonal anatase TiO2 and cassiterite SnO2 structures, respectively, without large variations to the film topography. The chemical composition of the as-deposited and annealed films was investigated through X-ray photoelectron spectroscopy. While dopants are homogenously mixed, the ternary ALD to form Sn:TiOx and Ti:SnOx surprisingly does not follow the rule of mixtures, despite similarities in both the growth rates of binary SnOx and TiOx and the precursors used. This finding is also supported by spectroscopic ellipsometry. We postulate the deviation from the rule of mixtures is due to non-ideal surface chemistry of the binary ALD of SnOx. The optical bandgap of all films was quantified by the Tauc analysis and the valence band position was investigated by valence band X-ray photoelectron spectroscopy. Intra-bandgap states above the valence band maximum were observed for as-deposited Ti:SnOx and Sn:TiOx and ascribed to 5 s states from Sn2+ ions. The presence of these intra-bandgap states induces enhanced visible absorption and bathochromic shifts to the apparent bandgap for all as-deposited films. Annealing the films removes the intra-bandgap states and increases the optical bandgap. Simplified band diagrams created using the data available demonstrated that the conduction and valence band positions did not vary between the positions of pure TiO2 or SnO2 with monotonic increases to the dopant incorporation.

Two-Dimensional Perovskite Crystals Formed by Atomic Layer Deposition of CaTiO3 on γ-Al2O3

Optical Properties of Al 2 O 3 Thin Film Fabricated by Atomic Layer Deposition

Room Temperature Formation of High‐Mobility Two‐Dimensional Electron Gases at Crystalline Complex Oxide Interfaces

Crystallization Behaviors of TiO2 Films Derived from Thermal Oxidation of Evaporated and Sputtered Titanium Films

Growth of Highly-Oriented CaCu 3 Ti 4 O 12 Thin Films on SrTiO 3 (1 0 0) Substrates by a Chemical Solution Route

Growth of highly-oriented CaCu3Ti4O12 thin films on SrTiO3 (100) substrates by a chemical solution route

Optical Constants and Band Gap Evolution with Phase Transition in Sub-20-nm-Thick TiO2 Films Prepared by ALD

Growth kinetics and crystallization behavior of TiO2 films prepared by plasma enhanced atomic layer deposition

Hydrothermal synthesis of perovskite CaTiO3 tetragonal microrods with vertical V-type holes along the [010] direction

Atomic Layer Deposition of Cerium Dioxide Film on TiN and Si Substrates: Structural and Chemical Properties

Mixed Tin-Titanium Oxides by Atomic Layer Deposition on Planar Substrates: Physical and Electronic Structure

Mechanical and Optical Properties of Cr2O3 Thin Films Grown by Atomic Layer Deposition Method Using Cr(thd)3 and Ozone

Crystallization of Titania Films in Aqueous Solutions and Their Dye Adsorption Properties

Epitaxial Growth of Dielectric CaCu3Ti4O12 Thin Films on (001) LaAlO3 by Pulsed Laser Deposition

Structural, chemical and optical properties of cerium dioxide film prepared by atomic layer deposition on TiN and Si substrates

Characterization and synthesis of cubic Zn2TiO4 crystalline films deposited on MgAl2O4 (100) substrates

Structural, morphological, and optical properties of TiO2 thin films grown by atomic layer deposition on fluorine doped tin oxide conductive glass

Atomic Layer Deposition of Tio2 from Tetrakis-Dimethyl-Amido Titanium or Ti Isopropoxide Precursors and H2o

Synthesis of titanium dioxide thin films via thermo- and plasma-enhanced atomic layer deposition

Resolving The Evolution Of Atomic Layer-Deposited Thin-Film Growth By Continuous In Situ X-Ray Absorption Spectroscopy

Observation of a two-dimensional electron gas at CaTiO$_3$ film surfaces