Abstract:The use of calcium oxide as a precipitant can achieve a nonammonia enrichment of a rare earth leaching liquor. However, an alkaline rare earth sulfate forms during the precipitation process, thus resulting in excessive SO42– content in the mixed rare earth oxides. Therefore, a stirring washing process for precipitation enrichment, which was obtained from calcium oxide precipitation, was investigated using a sodium hydroxide solution. It was determined that the Gibbs free energy of the stirring washing reaction, which was calculated by a group contribution method, was between −60 and −300 kJ/mol, depending on the different rare earth elements. The above results indicated that the reaction was thermodynamically feasible. The optimum conditions of the washing process were obtained, namely, a feed ratio of 2.85, a liquid–solid ratio of 6.5 mL/g, a stirring washing temperature of 35 °C, and a stirring washing time of 20 min. Under the optimal conditions, the purity and the SO42– content of the mixed rare earth oxides were 94.38% and 3.48%, respectively, and the stirring washing process with the sodium hydroxide solution had good recyclability. Moreover, the washing product was tested using thermogravimetry-differential thermal analysis (TG-DTA), X-ray diffraction (XRD), and scanning electron microscopy-energy-dispersive spectrometry (SEM-EDS), which verified that the stirring washing process with NaOH could effectively remove SO42– from the precipitation enrichment into solution. On this basis, a new extraction process of the ion-adsorption-type rare earth ore by magnesium salt leaching–calcium oxide precipitation–sodium hydroxide stirring washing is proposed. This new process can eliminate the traditional aluminum-removal process and effectively reduces the rare earth loss in the process. It can also solve the problem of the excessive SO42– content in the mixed rare earth oxides caused by the calcium oxide precipitation process. The research in this paper can have great significance for green, efficient extraction of the ion-adsorption-type rare earth ore and the improvement of resource utilization.This article has not yet been cited by other publications.

Simultaneous precipitation removal of fluoride ion and chloride ion from smelting waste acid using renewable remover

Removal of Fluoride from Geothermal Water by Waste-Synthesized Al(OH)3-HAP@ZMS Composite Adsorbent: Sorption Capability and Mechanism

The removal of chloride from washing leachate of MSWI fly ash

Green and circular method for chloride separation from acid wastewater: Application in zinc smelter

Recycling of lithium and fluoride from LiF wastewater from LiF synthesis industry by solvent extraction

Simultaneous Removal of Fluorine and Chlorine from Zinc Sulfate Solution in Iron Precipitation Process

Stepwise extraction of lithium and potassium and recovery of fluoride from aluminum electrolyte wastes through calcification roasting-two-stage leaching

A clean process for chloridion removal from manganese sulfate electrolyte using bismuthyl sulfate

Efficient Coagulation Removal of Fluoride Using Lanthanum Salts: Distribution and Chemical Behavior of Fluorine

A novel precipitant for the selective removal of fluoride ion from strongly acidic wastewater: Synthesis, efficiency, and mechanism

A novel electrochemical method for the removal of aluminum from ionic rare earth leachate

Chloride Ion Removal from the Wet Flue Gas Desulfurization and Denitrification Wastewater Using Friedel’s Salt Precipitation Method

Novel Technology for the Removal of Fe and Al from Spent Li-Ion Battery Leaching Solutions by a Precipitation–Complexation Process

Simultaneous removal of Al3+, Mg2+ and F- from wet-process phosphoric acid achieved by a co-precipitation strategy

Removal of Aluminum from Rare-Earth Leaching Solutions Via a Complexation-Precipitation Process

An integrated separation technology for high fluoride-containing wastewater treatment: Fluoride removal, membrane fouling behavior and control

A Novel Process for the Recovery of Rare Earth and Fluoride Compounds from Calciothermic Reduction Slag

A Superior Technology for Removing Fluorine from Spent Cathode Carbon: Optimization of the Process by Response Surface Methodology

Electrochemical removal of fluoride ions from industrial wastewater

A Review on the Removal of Magnesium and Fluoride in Zinc Hydrometallurgy

Removal of Sulfate Ions from Calcium Oxide Precipitation Enrichment of a Rare Earth Leaching Liquor by Stirring Washing with Sodium Hydroxide