Abstract:Owing to their intrinsic (geometry dependent) radiation hardness, 3D pixel sensors are promising candidates for the innermost tracking layers of the forthcoming experiment upgrades at the Phase 2 High-Luminosity LHC (HL-LHC). To this purpose, extreme radiation hardness up to the expected maximum fluence of 2e16 <a class="link-external link-http" href="http://neq.cm" rel="external noopener nofollow">this http URL</a>-2 must come along with several technological improvements in a new generation of 3D pixels, i.e., increased pixel granularity (50x50 or 25x100 um2 cell size), thinner active region (~100 um), narrower columnar electrodes (~5 um diameter) with reduced inter-electrode spacing (~30 um), and very slim edges (~100 um). The fabrication of the first batch of these new 3D sensors was recently completed at FBK on Si-Si direct wafer bonded 6-inch substrates. Initial electrical test results, performed at wafer level on sensors and test structures, highlighted very promising performance, in good agreement with TCAD simulations: low leakage current (<1 pA/column), intrinsic breakdown voltage of more than 150 V, capacitance of about 50 fF/column, thus assessing the validity of the design approach. A large variety of pixel sensors compatible with both existing (e.g., ATLAS FEI4 and CMS PSI46) and future (e.g., RD53) read-out chips were fabricated, that were also electrically tested on wafer using a temporary metal layer patterned as strips shorting rows of pixels together. This allowed a statistically significant distribution of the relevant electrical quantities to be obtained, thus gaining insight into the impact of process-induced defects. A few 3D strip test structures were irradiated with X-rays, showing inter-strip resistance of at least several GOhm even after 50 Mrad(Si) dose, thus proving the p-spray robustness. We present the most important design and technological aspects, and results obtained from the initial investigations.

Silicon sensors with resistive read-out: Machine Learning techniques for ultimate spatial resolution

Resistive Read-out in Thin Silicon Sensors with Internal Gain

First experimental results of the spatial resolution of RSD pad arrays read out with a 16-ch board

High-Precision 4D Tracking with Large Pixels using Thin Resistive Silicon Detectors

Machine learning for precise hit position reconstruction in Resistive Silicon Detectors

High performance picosecond- and micron-level 4D particle tracking with 100% fill-factor Resistive AC-Coupled Silicon Detectors (RSD)

Measurements and TCAD simulations of innovative RSD and DC-RSD LGAD devices for future 4D tracking

First test beam measurement of the 4D resolution of an RSD 450 microns pitch pixel matrix connected to a FAST2 ASIC

A Two-Prong Approach to the Simulation of DC-RSD: TCAD and SPICE

First test beam measurement of the 4D resolution of an RSD pixel matrix connected to a FAST2 ASIC

First investigation of a novel 2D position-sensitive semiconductor detector concept

Position-Sensitive Silicon Photomultiplier Arrays with Large-Area and Sub-Millimeter Resolution

Characterization of irradiated RD53A pixel modules with passive CMOS sensors

First FBK Production of 50$μ$m Ultra-Fast Silicon Detectors

High-Precision Contactless Optical 3D-Metrology of Silicon Sensors

A Fingertip-Mimicking 12×16 200μm-Resolution e-skin Taxel Readout Chip with per-Taxel Spiking Readout and Embedded Receptive Field Processing

Characterization of passive CMOS sensors with RD53A pixel modules

Monolithic integrated optoelectronic chip for vector force detection

Radiation tolerant, thin, passive CMOS sensors read out with the RD53A chip

Cluster-Locating Algorithm Based on Deep Learning for Silicon Pixel Sensors

First Production of New Thin 3D Sensors for HL-LHC at FBK