Abstract:Owing to their intrinsic (geometry dependent) radiation hardness, 3D pixel sensors are promising candidates for the innermost tracking layers of the forthcoming experiment upgrades at the Phase 2 High-Luminosity LHC (HL-LHC). To this purpose, extreme radiation hardness up to the expected maximum fluence of 2e16 <a class="link-external link-http" href="http://neq.cm" rel="external noopener nofollow">this http URL</a>-2 must come along with several technological improvements in a new generation of 3D pixels, i.e., increased pixel granularity (50x50 or 25x100 um2 cell size), thinner active region (~100 um), narrower columnar electrodes (~5 um diameter) with reduced inter-electrode spacing (~30 um), and very slim edges (~100 um). The fabrication of the first batch of these new 3D sensors was recently completed at FBK on Si-Si direct wafer bonded 6-inch substrates. Initial electrical test results, performed at wafer level on sensors and test structures, highlighted very promising performance, in good agreement with TCAD simulations: low leakage current (<1 pA/column), intrinsic breakdown voltage of more than 150 V, capacitance of about 50 fF/column, thus assessing the validity of the design approach. A large variety of pixel sensors compatible with both existing (e.g., ATLAS FEI4 and CMS PSI46) and future (e.g., RD53) read-out chips were fabricated, that were also electrically tested on wafer using a temporary metal layer patterned as strips shorting rows of pixels together. This allowed a statistically significant distribution of the relevant electrical quantities to be obtained, thus gaining insight into the impact of process-induced defects. A few 3D strip test structures were irradiated with X-rays, showing inter-strip resistance of at least several GOhm even after 50 Mrad(Si) dose, thus proving the p-spray robustness. We present the most important design and technological aspects, and results obtained from the initial investigations.

Radiation tolerant, thin, passive CMOS sensors read out with the RD53A chip

Characterization of irradiated RD53A pixel modules with passive CMOS sensors

Characterization of passive CMOS sensors with RD53A pixel modules

Design and Performance of HV CMOS Sensors for Future Colliders by the RD50 Collaboration

Radiation-Hard Active Pixel Sensors for Hl-Lhc Detector Upgrades Based on Hv-Cmos Technology

Characterization of passive CMOS strip sensors

Characterization of Fully Depleted CMOS Active Pixel Sensors on High Resistivity Substrates for Use in a High Radiation Environment

Design and characterization of ionizing radiation-tolerant CMOS APS image sensors up to 30 Mrd (Si) total dose

Progress on the radiation tolerance of CMOS Monolithic Active Pixel Sensors

A Radiation-Hardened CMOS Image Sensor With Pixels Exhibiting a Negligibly Small Dark-Level Increase During Ionizing Radiation

Characterization of the RD50-MPW4 HV-CMOS pixel sensor

RD50-MPW: a series of monolithic High Voltage CMOS pixel chips with high granularity and towards high radiation tolerance

Characterisation of 3D trench silicon pixel sensors irradiated at 1⋅1017 1 MeV neqcm-2

Radiation hardness studies of AMS HV-CMOS 350 nm prototype chip HVStripV1

Radiation hardness study on a CMOS pixel sensor for charged particle tracking

Characterisation of AMS H35 HV-CMOS monolithic active pixel sensor prototypes for HEP applications

Radiation effects on a radiation-tolerant CMOS active pixel sensor

Evaluation of Planar Silicon Pixel Sensors with the RD53A Readout Chip for the Phase-2 Upgrade of the CMS Inner Tracker

Signal height in silicon pixel detectors irradiated with pions and protons

First Production of New Thin 3D Sensors for HL-LHC at FBK

Radiation Tolerance of SiGe BiCMOS Monolithic Silicon Pixel Detectors without Internal Gain Layer