Abstract:Cu/MgO-Al2O3 (Mg/Al atomic ratio=1/1, 3/1, 4/1), Cu/MgO and Cu/Al2O3 catalysts with high Cu dispersions were prepared by an impregnation method using ethanol as solvent instead of water. Compared to water, ethanol as solvent was favorable not only for obtaining the high dispersions of the Cu clusters on the basic oxide supports, but also for retaining the basicity and structures of the supports during the catalyst preparation. The density of the basic sites for the dispersed Cu catalysts increased with increasing the MgO contents in the basic supports. These catalysts catalyzed glycerol hydrogenolysis to propylene glycol with a high selectivity (>90%), and showed slight deactivation in dioxane at 200 degrees C and 6.0 MPa H-2. Their reaction rates normalized by per exposed Cu atom increased with increasing the ratios of the basic sites to Cu atoms on the catalyst surfaces. The intrinsic hydrogenolysis activity of the Cu atoms were probed by N2O chemisorption-H-2 temperature programmed reduction, which did not change essentially with the Cu loadings (2-6 wt%) and the Mg/Al atomic ratios of the MgO-Al2O3 supports. Meanwhile, the basic sites alone on the supports were inactive for the glycerol conversion. Taken together, we propose a synergetic effect that the basic sites at the interfaces between the Cu sites and the supports assist the cleavage of alpha-C-H bonds of glycerol on the Cu surfaces leading to the faster dehydrogenation of glycerol to glyceraldehyde, a kinetically-relevant step in glycerol hydrogenolysis to propylene glycol. These active basic sites appear to be the Bronsted OH- sites, i.e. the hydroxyl groups bonded to the surface Mg2+ cations on MgO-Al2O3. The understanding on such synergy between the basic sites and Cu sites in glycerol hydrogenolysis provides a basis for the rational design of superior hydrogenolysis catalysts and selective removal of oxygen from biomass-derived feedstocks.

Study of the Glycerol Hydrogenolysis Reaction on Cu, Cu–Zn, and Cu–ZnO Clusters

Theoretical Investigation on the CO2 Hydrogenation to Methanol Mechanism at Electron-Rich Active Interface over Cu/Ga-Ti-Al-O Catalyst

Selective Hydrogenolysis of Glycerol to Propylene Glycol on Cu–ZnO Composite Catalysts: Structural Requirements and Reaction Mechanism

Understanding the Reaction Mechanism of Glycerol Hydrogenolysis over a CuCr2 O4 Catalyst

Role of Initial Water Content in Glycerol Hydrogenolysis to 1,2-Propanediol over Cu–ZnO Catalyst

Selective hydrogenolysis of glycerol to propylene glycol on Cu–ZnO catalysts

Kinetics of Hydrogenolysis of Glycerol to Propylene Glycol over Cu-Zno-Al2o3 Catalysts

Insights into Deactivation Mechanism of Cu–ZnO Catalyst in Hydrogenolysis of Glycerol to 1,2-Propanediol

Selective hydrogenolysis of raw glycerol to 1,2-propanediol over Cu–ZnO catalysts in fixed-bed reactor

Selective Hydrogenolysis of Glycerol to Propylene Glycol on Hydroxycarbonate-Derived Cu-Zno-Al2o3 Catalysts

Selective Hydrogenolysis of Glycerol to Propylene Glycol on MgO-Al2O3 Dispersed Cu Catalysts

Biodiesel Derived Glycerol Hydrogenolysis to 1,2-Propanediol on Cu/Mgo Catalysts

Hydrogenolysis of Glycerol over Cu0.4/Zn5.6−xMgxAl2O8.6 Catalysts: the Role of Basicity and Hydrogen Spillover

Identification of Synergistic Actions Between Cu0 and Cu+ Sites in Hydrogenation of Dimethyl Oxalate from Microkinetic Analysis

Synthesis, Characterisation, and Evaluation of Stable, Efficient Modified Nanocopper-Based Glycerol Hydrogenolysis Catalysts

Structure-reactivity relations in Cu/ZrO2 catalysed glycerol dehydration to acetol in continuous flow system

Understanding the Synergistic Catalysis in Hydrogenation of Carbonyl Groups on Cu-Based Catalysts

Hydrogenolysis of glycerol to 1,2-propanediol over Cu-based catalysts: A short review

Unraveling the catalytically active phase of carbon dioxide hydrogenation to methanol on Zn/Cu alloy: Single atom versus small cluster

Ni Doped Cu-ZnO Catalyst for Glycerol Hydrogenolysis

Hydrogenolysis of glycerol over homogenously dispersed copper on solid base catalysts