Abstract:Three Cu-ZnO-Al2O3 catalysts with similar compositions were prepared by homogeneous coprecipitation (CZA-HP), deposition-precipitation (CZA-DP), and conventional coprecipitation (CZA-CP). A Cu-ZnO catalyst was also prepared by homogeneous coprecipitation (CZ-HP) for reference. X-ray diffraction results showed that the degree of mixing of Cu2+, Zn2+, and Al3+ ions in the Cu-Zn-Al hydroxycarbonate precursor followed the order of CZA-DP < CZA-HP < CZA-CP. A more homogeneous aluminum distribution and intimate contact between Al2O3 and ZnO led to smaller CuO and ZnO crystallites in the CuO-ZnO-Al2O3 composite oxides, and consequently smaller Cu and ZnO crystallites in the final Cu-ZnO-Al2O3 catalysts. However, the intimate ZnO-Al2O3 contact hindered the interaction between Cu and ZnO in the Cu-ZnO-Al2O3 catalysts. As a result of these effects of Al2O3, for the samples other than CZA-CP, the Cu particles on CZA-HP showed the highest redox activity, which was characterized by N2O chemisorption-H2 temperature-programmed reduction. These catalysts catalyzed glycerol hydrogenolysis to propylene glycol with high selectivities above 90% at 30% glycerol conversion (473 K and 6.0 MPa H2). Their activities normalized per exposed surface Cu atom to give turnover frequencies increased in the order CZA-DP < CZA-CP < CZ-HP < CZA-HP, which was the order of the redox ability of the Cu particles. The addition of alumina increased the stability of Cu-ZnO catalysts. After six cycles (6 h per run), the activity of CZ-HP decreased by 45% accompanied by an increase of Cu crystallite size from 13.2 to 45.2 nm, while that of CZA-HP decreased only by 10% with an increase of the Cu crystallite size from 8.3 to 19.0 nm. These results demonstrated the promoting effects of Al2O3 on the activity and stability of Cu-ZnO catalysts derived from the hydroxycarbonates.

Preparation of Highly Dispersed Cu Catalysts from Hydrotalcite Precursor for the Dehydrogenation of 1,4-Butanediol

Catalytic Hydrogenation of γ-Butyrolactone to Butanediol over a High-Performance Cu-SiO2 Catalyst

Preparation of Cu/Sba-15 Catalysts by Different Methods for the Hydrogenolysis of Dimethyl Maleate to 1,4-Butanediol

Hydrogenolysis of glycerol over homogenously dispersed copper on solid base catalysts

Co-production of Hydrogen and Acetaldehyde from Ethanol over a Highly Dispersed Cu Catalyst

Super solid-base supported Cu catalysts for hydrogenolysis of glycerol to 1,2-propanediol

Deactivation of Cu/ZSM-5 Catalysts during the Conversion of 2,3-Butanediol to Butenes

Preparation of Γ-Butyrolactone from 1,4-Butanediol Dehydrogenation over Cu/ZnO/Al2O3 Catalyst

Preparation of Cu/ZnO/Al2O3 Catalysts in a Solvent-Free Routine for CO Hydrogenation

Ni-Based Hydrotalcite (HT)-Derived Cu Catalysts for Catalytic Conversion of Bioethanol to Butanol

Catalytic conversion of syngas to mixed alcohols over CuFe-based catalysts derived from layered double hydroxides

Synthesis of a Cu@ZnO1-x/Al2O3 Catalyst with High-Density ZnO1-x-Cu Interfacial Sites for Enhanced CO2 Hydrogenation to Methanol

Synthesis Of Higher Alcohol Mixtures From Syngas Over Modified Copper Catalysts

Selective Hydrogenolysis of Glycerol to Propylene Glycol on Hydroxycarbonate-Derived Cu-Zno-Al2o3 Catalysts

High-Performance Cu/ZnO/Al 2 O 3 Catalysts for CO 2 Hydrogenation to Methanol

Liquid-phase preparation of CuO/ZrO2 catalyst used in slurry reactors and its catalytic activity for CO hydrogenation

Efficient Tuning of Surface Copper Species of Cu/SiO2 Catalyst for Hydrogenation of Dimethyl Oxalate to Ethylene Glycol

A practical approach for the preparation of high activity Cu/ZnO/ZrO2 catalyst for methanol synthesis from CO2 hydrogenation

Formic acid assisted synthesis of Cu-CuO-ZnO composite catalyst for acceptor free selective dehydrogenation of 1, 4-butanediol to γ-butrylactone

Investigation of the Structural Evolution and Catalytic Performance of the Cuznal Catalysts in the Hydrogenation of Dimethyl Oxalate to Ethylene Glycol

Hydrogenolysis of Glycerol over Cu0.4/Zn5.6−xMgxAl2O8.6 Catalysts: the Role of Basicity and Hydrogen Spillover