Abstract:With the advent and development of power semiconductor switches like IGBT or MOSFET, high-speed switching devices have sprung up and sped up dynastic response of converters. However, these devices in operation will produce very large dv/dt and di/dt, which result in sever electromagnetic interference(EMI). In a variable-frequency drive(VFD) system, due to the coupling common-mode(CM) noise, communication between programmable logic controller(PLC) and VFD will be affected by CM current at the motor side if communication cables get too close to the motor ones. This paper emphatically analyzes the effect of common-mode interference on communication performance of a motor drive system. It introduces the generation mechanism of CM voltage and current at the motor side in a VFD system first and briefly illustrates how it couples to the communication cables. At the same time, some certain influence factors of CM current in communication system are respectively explained. Then it elaborates the detailed mechanism how CM current on communication cables affects the error rate which is employed to evaluate the communication quality. Besides, the numerical relationship between CM current on communication cables and the error rate is also discussed and confirmed by series of experiments. Finally, some software or hardware solutions are put forward to achieve the aim of interference suppression and decreasing the error rate when CM current on communication cables is constant.

Research Status of Conducted Common Mode EMI Restraint Method in PWM Motor Drive System

Research on PWM Method in Brushless DC Motor

Comparative Study of Flux-Weakening Control Methods for Pmsm Drive over Wide Speed Range

Modeling of Conducted EMI in Motor Drive System Based on Double Pulse Test and Impedance Measurement

Analysis of EMI in Motor System Driven by PWM Inverter

Prediction Model of Conducted Common-Mode EMI in PWM Motor Drive System

Analysis and Suppression of Common Mode Voltage for Motor Drive in EV

Effect of Common-Mode Interference on Communication Performance of a Motor Drive System

Time-frequency Characteristics Research of Common Mode Current in PWM Motor System

Impact of reduced common mode voltage PWM and common mode inductor on EMI characteristics of an inverter-driven motor

Estimation of Common-Mode Current Coupled to the Communication Cable in a Motor Drive System

Suppression Method of Conducted EMI in Motor Driven System

Eliminating Common Mode Voltage and Suppressing Conducted EMI Based on Discontinuous PWM for General Two-Unit PMSMs

Analysis and Suppression of Common-Mode Voltage in Open-End Winding Induction Motor Drive System Fed by Dual Inverter

Research of electromagnetic compatibility of motor drive system applied in electric vehicle

Novel Π-Type Conducted Common-mode EMI Model for Induction Machines

Influence of Periodic Carrier Frequency Modulation on Low Frequency Electromagnetic Interference of Permanent Magnet Synchronous Motor Drive System.

Research and analysis of electromagnetic interference of a motor drive control system based on PMSM with SiC MOSFET for new energy electric vehicles

Modeling And Evaluation Of Common-Mode Interference Coupling Effects On Sensitive Cable In Motor Drive System

Research of common-mode voltage elimination for open-end winding AC motor drive system

Modeling and suppression of PWM inverter's adverse effects