Abstract:This work presents a facile sol-gel method for the deposition of ZnO and ZnO:Mg films. The films are spin coated on silicon and quartz substrates. The impact of magnesium concentrations (0, 0.5, 1, 2 and 3 wt%) and post-annealing treatments (300-600 °C) on the film's structural, vibrational and optical properties is investigated. Undoped ZnO films crystallize in the wurtzite phase, with crystallite sizes ranging from 9.1 nm (300 °C) to 29.7 nm (600 °C). Mg doping deteriorates the film crystallization and shifting of 002 peak towards higher diffraction angles is observed, indicating the successful incorporation of Mg into the ZnO matrix. ZnO:Mg films (2 wt%) possess the smallest crystallite size, ranging from 6.2 nm (300 °C) to 25.2 nm (600 °C). The highest Mg concentration (3 wt%) results into a segregation of the MgO phase. Lattice constants, texture coefficients and Zn-O bond lengths are discussed. The diminution of the c lattice parameter is related to the replacement of Zn2+ by Mg2+ in the ZnO host lattice. The vibrational properties are studied by Fourier transform infrared (FTIR) spectroscopy. IR lines related to Mg-O bonds are found for ZnO:Mg films with dopant concentrations of 2 and 3 wt%. The optical characterization showed that the transmittance of ZnO:Mg thin films increased from 74.5% (undoped ZnO) to about 89.1% and the optical band gap energy from 3.24 to 3.56 eV. Mg doping leads to a higher refractive index compared to undoped ZnO films. The FESEM (field emission scanning electron microscopy) technique is used for observation of the surface morphology modification of ZnO:Mg films. The doped ZnO films possess a smoother grained surface structure, opposite to the wrinkle-type morphology of undoped sol-gel ZnO films. The smoother surface leads to improved transparency of ZnO:Mg films.

Mg doping effects on the microstructure and piezoelectric characteristics of ZnO:Li films deposited at room temperature using an RF sputtering deposition method

Preparation and Characterization of Mg-doped ZnO Thin Films by Sol–gel Method

Effect of Magnesium Doping on the Light-Induced Hydrophilicity of Zno Thin Films

Microstructue and Optical Properties of Mg-doped ZnO Thin Films Prepared by Sol-gel Method

Effect of Mg Content on Structural, Electrical, and Optical Properties of Li-doped Zn1−xMgxO Thin Films

The effect of Mg doping concentration and annealing on the structure and luminescence properties of ZnO thin films

Effect of process parameters on microstructure and Raman characteristics of magnesium doped ZnO thin films

Photoluminescence of diluted Mg doped ZnO thin films and band-gap change mechanisms

Optical and structural properties of Mg doped ZnO thin films by chemical bath deposition method

Sol–gel derived (Li, Mg): ZnO films with high c-axis orientation and electrical resistivity

Enhanced secondary electron emission properties of Zn doped MgO thin films prepared by aerosol assisted chemical vapor deposition

Structural, electronic, and optical study of Zn: MgO compositions by computational and experimental approach

Effect of Mg doping on the hydrogen-sensing characteristics of ZnO thin films

Comparison of Li+-doping sources on properties of ZnO piezoelectric films

Fabrication of P-Type ZnMgO Films Via Pulsed Laser Deposition Method by Using Li As Dopant Source

Characterization and doping effects study of high hole concentration Li-doped ZnO thin film prepared by sol–gel method

Effects of Mg Content on the Optical Properties of MgZnO Fims

Effect of Zr Concentration on Microstructure and Discharge Properties of Mg-Zr-O Films Deposited by Magnetron Sputtering

The Effect of Mg and Al Co-Doping on the Structural and Photoelectric Properties of ZnO Thin Film

The Structural, Electrical and Optical Properties of Mg-doped ZnO with Different Interstitial Mg Concentration

Deposition of Sol-Gel ZnO:Mg Films and Investigation of Their Structural and Optical Properties