Abstract:The nucleation and growth mechanism of electrodeposited Ni−W alloy were investigated. Cyclic voltammetry (CV) and chronoamperometry (CA) were used to examine the electrochemical behavior and nucleation mechanism of the electrodeposited Ni−W alloy. The nucleation type and kinetic parameters of the electrodeposited Ni−W alloy were obtained from the CA analysis results. SEM, AFM, and TEM were also used to investigate the nucleation and growth process of the electrodeposition of Ni−W alloy. The results demonstrate that the nucleation and initial stages of the growth phase of the Ni−W alloy undergo the formation, movement, and aggregation of atoms, single crystals, and nanoclusters. When the size of single crystal increases up to approximately 10 nm and the average size of the crystal granules is approximately 68 nm, they no longer grow. Increasing the applied potential increases the number of nuclei but does not affect the size of the final crystal granules. Therefore, the electrodeposited Ni−W alloy shows a nanocrystalline structure.

What problem does this paper attempt to address?

The paper aims to study the nucleation and growth mechanisms of electrodeposited Ni-W alloys. Specifically, the authors investigate the electrochemical behavior and nucleation mechanism using cyclic voltammetry (CV) and chronoamperometry (CA), and study the nucleation and growth process of Ni-W alloys during electrodeposition using scanning electron microscopy (SEM), atomic force microscopy (AFM), and transmission electron microscopy (TEM). The main research contents include: 1. **Nucleation and Growth Process**: The study found that in the initial stage of electrodeposition, Ni-W alloys form single crystals with a diameter of approximately 2.5 nanometers. These single crystals then grow to about 10 nanometers through the movement and aggregation of atoms and nanocrystals. Further observations revealed that small-sized nanocrystals and nanoclusters continue to move and aggregate to form crystal particles with a diameter of approximately 68 nanometers. 2. **Effect of Overpotential**: Increasing the applied overpotential can increase the nucleation density but does not affect the final size of the crystal particles. 3. **Electrochemical Characterization**: The crystal structure and grain size of electrodeposited Ni-W alloys were analyzed by X-ray diffraction (XRD), and the results showed that they have a nanocrystalline structure. In summary, this paper aims to gain an in-depth understanding of the nucleation and growth mechanisms of Ni-W alloys during the electrodeposition process and to explore the effects of different overpotential conditions.

Nucleation and growth mechanism of electrodeposited Ni−W alloy

A Study on the Electrodeposition Behaviors of Nickel-iron-tungsten Alloy

Electrocrystallization Nucleation and Growth of NiFe Alloys on Brass Substrate

Preparation and Properties of Textured Ni–W Coatings Electrodeposited on the Steel Surface from a Pyrophosphate Bath

Electrochemical Deposition and Nucleation/Growth Mechanism of Ni–Co–Y2O3 Multiple Coatings

Growth Kinetics of Nickel Crystals in Nanopores

Electrochemical fabrication and structure of Ni<sub><i>x</i></sub>Zn<sub>1−<i>x</i></sub> alloy nanowires

Electrodeposition of nanocrystalline Ni-W coatings with citric acid system

Influences of Co and process parameters on structure and corrosion properties of nanocrystalline Ni-W-Co ternary alloy film fabricated by electrodeposition at low current density

Structural, magnetic, and magnetoresistive properties of electrodeposited Ni5Zn21 alloy nanowires.

Electrochemical co-deposition of carbon nanotube/Ni composite layer

Electrochemical study and structural comparison of Ni electrodepositions on W/Si and Cr/C multilayered structure films

Morphological stabilization and KPZ scaling by electrochemically induced co-deposition of nanostructured NiW alloy films

Influence of Nano-Al2O3 Particles on Nickel Electrocrystallization at Initial Stage

Effect of Tungsten on Microstructures of Annealed Electrodeposited Ni-W Alloy and Its Corrosion Resistance

Electrolytic Synthesis and Characterization of Electrocatalytic Ni-W Alloy

Growth Behavior of Ni on Hydrogen-Etched WS2 Surface

Electrochemical study of Ni deposition on carbon microfiber

Microstructure and wear properties of crystalline W alloy coatings prepared by electrodeposition

Nucleation and growth mechanism of dendrite-free Ni–Cu catalysts by magneto-electrodeposition for the hydrogen evolution reaction

Coating process conditions of W alloy electrodeposition