Abstract:Gallium nitride (GaN)-based high electron mobility transistor (HEMT) power devices have demonstrated great potential applications due to high current density, high switching speed, and low ON-resistance in comparison to the established silicon (Si)-based semiconductor devices. These superior characteristics make GaN HEMT a promising candidate for next-generation power converters. Many of the early GaN HEMTs are devices with Schottky gate, which suffer a high gate leakage and a small gate swing. By inserting an insulator under gate metal, the MIS-HEMT is highly preferred over the Schottky-gate HEMT for high-voltage power switche, owing to the suppressed gate leakage and enlarged gate swing. However, the insertion of the gate dielectric creates an additional dielectric/(Al) GaN interface that presents some great challenges to AlGaN/GaN MIS-HEMT, such as the threshold voltage (Vth) hysteresis, current collapse and the reliability of the devices. It has been reported that the poor-quality native oxide (GaOx) is detrimental to the dielectric/(Al) GaN interface quality that accounted for the Vth instability issue in the GaN based device. Meanwhile, it has been proved that in-situ plasma pretreatment is capable of removing the surface native oxide. On the other hand, low power chemical vapor deposition (LPCVD)-Si3N4 with free of plasma-induced damage, high film quality, and high thermal stability, shows great potential applications and advantages as a choice for the GaN MIS-HEMTs gate dielectric and the passivation layer. In this work, an in-situ pre-deposition plasma nitridation process is adopted to remove the native oxide and reduce surface dangling bonds prior to LPCVD-Si3N4 deposition. The LPCVD-Si3N4/GaN/AlGaN/GaN MIS-HEMT with a high-quality LPCVD-Si3N4/GaN interface is demonstrated. The fabricated MIS-HEMT exhibits a very-low Vth hysteresis of 186 mV at VG-sweep=(-30 V, +24 V), a high breakdown voltage of 881 V, with the substrate grounded. The hysteresis of our device at a higher positive end of gate sweep voltage (VG +20 V) is the best to our knowledge. Switched off after an off-state VDS stress of 400 V, the device has a dynamic on-resistance Ron only 36% larger than the static Ron.

A High Performance Normally-Off AlGaN/GaN Split-Gate Metal-Insulator-Semiconductor High Electron Mobility Transistor (MIS-HEMT) Using Piezo Neutralization Technique

Normally OFF GaN-on-Si MIS-HEMTs Fabricated with LPCVD-SiN X Passivation and High-Temperature Gate Recess

Improving Performance and Breakdown Voltage in Normally-Off GaN Recessed Gate MIS-HEMTs Using Atomic Layer Etching and Gate Field Plate for High-Power Device Applications

Normally-Off p-GaN Gated AlGaN/GaN MIS-HEMTs with ALD-Grown Al2O3/AlN Composite Gate Insulator

High-performance AlGaN/GaN MIS-HEMT Device Based on in Situ Plasma Nitriding and Low Power Chemical Vapor Deposition Si3N4 Gate Dielectrics

High Performance AlGaN/GaN Power Switch with Si3N4insulation

AlGaN/GaN MISHEMTs with AlN Gate Dielectric Grown by Thermal ALD Technique

Normally-OFF AlGaN/GaN MIS-HEMTs With Low R ON and V th Hysteresis by Functioning In-situ SiN x in Regrowth Process

Normally Off AlGaN/GaN MIS-High-Electron Mobility Transistors Fabricated by Using Low Pressure Chemical Vapor Deposition Si<sub>3</sub>N<sub>4</sub> Gate Dielectric and Standard Fluorine Ion Implantation

A new gate design combined MIS and p-GaN gate structures for normally-off and high on-current operation

Fabrication of High-Uniformity and High-Reliability Si 3 N 4 /algan/gan MIS-HEMTs with Self-Terminating Dielectric Etching Process in a 150-Mm Si Foundry

Low ON-State Resistance Normally-OFF AlGaN/GaN MIS-HEMTs with Partially Recessed Gate and ZrOₓ Charge Trapping Layer

Normally-off Fully Recess-Gated GaN Metal–insulator–semiconductor Field-Effect Transistor Using Al2O3/Si3N4 Bilayer As Gate Dielectrics

AlGaN/GaN MIS-HEMT with PECVD SiNx, SiON, SiO2 as Gate Dielectric and Passivation Layer

High-performance normally off p-GaN gate high-electron-mobility transistor with In 0.17 Al 0.83 N barrier layer design

Interface charge engineering on an in situ SiN x /AlGaN/GaN platform for normally off GaN MIS-HEMTs with improved breakdown performance

Threshold Voltage Instability in III-nitride Heterostructure Metal–insulator–semiconductor High-Electron-mobility Transistors: Characterization and Interface Engineering

On-chip AlGaN/GaN HEMTs with the Compatible Normally-off p-GaN Gate and Normally-on MIS Gate Fabrication Processes

A Non-Ohmic Normally-off GaN RB-MISHEMT Featuring a Gate-Controlled Schottky Tunnel Junction

Low Threshold Voltage Shift in AlGaN/GaN MIS-HEMTs on Si Substrate Using SiNx/SiON As Composite Gate Dielectric

Normally-Off Algan/Gan Moshfet Using Ald Sio2 Tunnel Dielectric and Ald Hfo2 Charge Storage Layer for Power Device Application