Abstract:The principal aim of this study is to reduce considerably, via Sn doping, the resistivity of ZnO thin films prepared by simple, flexible, and cost-effective nitrogen pneumatic spray pyrolysis (NPSP) method on glass substrates at a temperature of 400°C. Different Sn content was tested (Sn/Zn = 0, 1, 3, 5 wt%) in an attempt to reduce the concentration of excessive oxygen atoms and create more free electrons. The microstructural, optical, morphological, and electrical properties of the films have been studied. The x-ray diffraction analysis demonstrated that tin-doped SZO films exhibited polycrystalline nature with a preferential orientation along (002) plane with the appearance of a new orientation (101) with the increase of Sn concentration leading then to bidirectional growth. The deposited SZO films showed an average optical transmittance of about 80% in the UV-visible region (200-800 nm) with optical band gap values at around 3.27 eV. Photoluminescence emissions of SZO samples presented three main peaks: near band edge emission, violet emission, and the blue-green emission. The surface morphology of the films obtained by scanning electron microscope (SEM) exhibited the change in morphology with increasing the Sn content. A minimum electrical resistivity value of about 17·10-3 Ω·cm was obtained for 3% SZO films. SZO films prepared by the NPSP method can be used as transparent window layer and electrodes in solar cells. RESEARCH HIGHLIGHTS: Highly oriented, conducting, and transparent Sn-doped ZnO films are successfully synthesized. The film growth orientation changed from mono-directional (002) axis to bi-directional (002) and (101) axis according to Sn doping. Ultraviolet and green emissions are noted by photoluminescence investigation. A minimum resistivity is observed for 3 wt% SZO film. The dual positive effect of the carrier gas used (N2) and Sn doping is confirmed.

Effect of Na Doping on Some Physical Properties of Chemically Sprayed CZTS Thin Films

Surface Morphology and Optical Properties of Na-doped ZnO Thin Films

Microstructure, surface morphology and optical properties of Na x Cu y Zn 1− x − y O thin films

Effect of Na Concentrations on Microstructure and Optical Properties of Zno Films

Sodium Doping Effects on the Crystalline and Electrical Properties of Cu2znsnse4 Thin Films

Optical Properties and UV Photoresponse of Na2x Zn1−x O Thin Film

Influence of Dopant Content on Morphology and Optical Constants of ZnO:Na Films by Sol-Gel Method

Preparation and Characterization of Na-doped ZnO Thin Films by Sol–gel Method

Effect of Na doping on the performance and the band alignment of CZTS/CdS thin film solar cell

Study on structural and optical properties of Sn-doped ZnO nanoarrays

Structural, Morphological and Optical Characterization of Tin Doped Zinc Oxide Thin Film by (SPT)

Dual effect to improve the electrical properties of SZO films grown by nitrogen pneumatic spray pyrolysis

Effect of Substrate and Zn Doping on the Structural, Optical and Electrical Properties of Cds Thin Films Prepared by Cbd Method

Unravelling the effects of Zn doping on the physical properties of Co3O4 thin films: experimental study and numerical simulation based on the AZO/ZnS/Co3O4:Zn/Mo/SLG solar cells

The Optical Influence of Na on Cu 2 ZnSnSe 4 Films Deposited with Na-containing Sol–gel Precursor

Study of optical and structural properties of CZTS thin films using copper capping layer and sulfurization to correct stoichiometry.

Enhancing the Optoelectronic Performance of CZTS Thin Films through Cobalt Doping via Nebulizer-Assisted Spray Pyrolysis Technique

Passivation of Grain Boundaries and Defects in CZTSSe Solar Cells by In Situ Na Doping

Effect of Na Doping Content on the Structural and Electrical Properties of ZnO∶Nax Films

First-Principles Study on Doping Effects of Sodium in Kesterite Cu2znsns4

Effect of sulfurization time on the properties of copper zinc tin sulfide thin films grown by electrochemical deposition