Abstract:The higher voltage blocking capability and faster switching speed of silicon-carbide (SiC) mosfets have the potential to replace Si insulated gate bipolar transistors (IGBTs) in medium-low-voltage and high-power applications. In this paper, a state-of-the-art commercially available 325 A, 1700 V SiC mosfet module has been fully characterized under various load currents, bus voltages, and gate resistors to reveal their switching capability. Meanwhile, Si IGBT modules with similar power ratings are also tested under the same conditions. From the test results, several interesting points have been obtained: different to the Si IGBT module, the over-shoot current of the SiC mosfet module increases linearly with the increase of the load current and it has been explained by a model of the over-shoot current proposed in this paper; the induced negative gate voltage due to the complementary device turn-off (crosstalk effect) is more harmful to the SiC mosfet module than the induced positive gate voltage during turn-on when the gate off-voltage is 6 V; the maximum dvdt and didt (electromagnetic interference) during switching transients of the SiC mosfet module are close to those of the Si IGBT module when the gate resistance is larger than 8 but the switching loss of the SiC mosfet module is much smaller; the switching losses of the Si IGBT module are greater than those of the SiC mosfet module even when the gate resistance of the former is reduced to zero. An accurate power loss model, which is suitable for a three-phase two-level converter based on SiC mosfet modules considering the power loss of the parasitic capacitance, has been presented and verified in this paper. From the model, a 96.2 efficiency can be achieved at the switching frequency of 80kHz and the power of 100 kW.

The Advantages and Applications of IGBT Compared with Conventional BJT and MOSFET

The trench Insulated Gate Bipolar Transistor— a high power switching device

An Experimental And Numerical Investigation Of Igbt Blocking Characteristics

Performance Compare and Test for Trenchstop and NPT IGBT

Optimum Design of 1.4kv Non-Punch-Through Trench Igbts: the Next Generation of High-Power Switching Devices

Analysis of Double Trench Insulated Gate Bipolar Transistor

Optimum design of 1.4 kV trench IGBTs-the next generation of high power switching devices

1.4 kV, 25 A, PT and NPT trench IGBTs with optimum forward characteristics

Performance Evaluation of High-Power SiC MOSFET Modules in Comparison to Si IGBT Modules

Silicon MOS Controlled Bipolar Power Switching Devices Using Trench Technology

Comparative Investigation of Surge Current Capabilities of Si IGBT and SiC MOSFET for Pulsed Power Application

Dynamic Performance of 6.5kv/400a SiC MOSFET Module and Its Gate Driver

The New Generation of Power Semiconductor Devices

Characteristics Of Trench Gate And Dmos Igbts In A Zcs Single-Ended Resonant Inverter

Characterising Trench Igbts in Resonant Switching Using Single Ended and Half-Bridge Application Circuits

Reverse-Conducting Insulated Gate Bipolar Transistor: A Review of Current Technologies

Thermal Management on IGBT Power Electronic Devices and Modules