Abstract:As MOSFET devices are scaled down to below 100nm, the gate oxide thickness is required below 2nm. Conventional SiO2 gate dielectric will be replaced due to excessive leakage and poor reliabilit y. Thus, high dielectrics constant (K) gate dielectrics are being studied as an alternative. High-K dielectrics materials such as CeO2, Y2O3, Ta2O5, HfO2, ZrO2, TiO2, Al2O3, SrTiO3(STO), and BaSrTiO3(BST) have are studied . Among them, HfO2 is a promising candidate due to its thermodynamic stabil ity on Si, high dielectric constant ( 25), and relatively large band gap (5.68eV). In the paper, ultra-thin HfO2 gate dielectrics films were fabricated, electrical and reliabili ty properties such as capacitance-voltage (C-V), current-voltage (I-V), stress induce leakage current (SILC) effects and breakdown characteristics were studied. In the experiment, HfO2 capacitor samples have been fabricated using the following process. P-type (100) sili con substrates with 5-8 cm resistivity were cleaned using H2SO4:H2O2 (2:1) solution and HF dip. Thin HfO2 layers were following deposited at room temperature by ion beam sputtering a sintered HfO2 target. Then they were annealed under various temperatures and ambient. After annealing, Pt top electrodes were deposited by sputtering. The area of the capacitors was 5 10cm. The C-V and I-V curves were measured using HP4156B semiconductor parameter analyzer and Keithley590 C-V analyzer. Figure 1 shows the capacitance-voltage (C-V) curves of HfO2 gate dielectrics. The largest value of measured capacitance density in accumulation is Cmax/A=11.6fF/ m. The equivalent oxide thickness (EOT) is about 2.9nm. Comparing capacitances of various annealing temperatures, the capacitance of the sample annealed at 400 is highest. With increase annealed temperatures, EOT increased. Figure 2 shows the current-voltage (I-V) characteristics of HfO2 gate dielectrics. The leakage current of the sample annealed at 800 is lowest, which is about 3.09 10A/cm at –1.5V gate voltage. No distinct SILC effect is obtained. The leakage current of the sample annealed at 400 after 1×10C/cm stress has a very lit tle diversification. With increase annealed temperatures, the leakage current and SILC effect reduced. Figure 3 shows breakdown characteristics of HfO2 dielectrics. The breakdown electric field of HfO2 dielectrics is more than 2×10MV/cm. With increase annealing temperatures, the breakdown voltages decreased. Consequently, ultra-thin HfO2 gate dielectrics (EOT<3nm) were fabricated. All samples annealed under various temperatures and N2 ambient have good electrical characteristic and reliabili ty. With increase annealing temperatures, EOT of increased, the leakage current and SILC effect reduced, the breakdown voltages decreased. References: [1] E.P. Gusev, E. Carier, D.A. Buchanan, M. Gribelyuk, M. Copel, H. Okorn-Schmidt, and C.D. Emic, Microelectronic Engineering 59(2001) 341-349 [2] Wen-jie Qi, Renee Nieh, Byoung Hun Lee, Laegu Kang, Yongjoo Jeon, and Jack C. Lee, Applied Physics Letters, 2000, 77(20): 3269-3271 [3] G.D. Wilk, and R.M. Wallace, Applied Physics Letters, 1999, 74(19): 2854-2856 [4] Kevin X. Zhang, Carlton M. Osbun, IEEE Trans. Electron Devices, 42(12), 1995, 2181-2188 [5] G.D. Wilk, R.M. Wallace, J.M. Anthony, Applied Physics Review, 2001, 89(10): 5243-5275

Pulsed Laser Deposited Dy and Ta doped Hafnium- Zirconium Oxide Thin Films for the high-k Applications

Microstructure, Optical and Electrical Properties of Sputtered HfTiO High-K Gate Dielectric Thin Films

Analysis of the Electrical Properties and Current Transportation Mechanism of a Metal Oxide Semiconductor (MOS) Capacitor Based on HfGdO Gate Dielectrics

Microstructure, Optical, Electrical Properties, and Leakage Current Transport Mechanism of Sol–gel-Processed High-K HfO2 Gate Dielectrics

Microstructure Optimization and Optical and Interfacial Properties Modulation of Sputtering-Derived Hfo2 Thin Films by Tio2 Incorporation

Microstructure, optical and electrical properties of solution-derived peroxo-zirconium oxide gate dielectrics for CMOS application

Thermal Stability and Electrical Properties of Pulsed Laser Deposited Hf–aluminate Thin Films for High-K Gate Dielectric Applications

Fabrication and Characterization of Pulsed Laser Deposited Hfo2 Films for High-K Gate Dielectric Applications

Atomic Layer Deposition of La:Hf0.5Zr0.5O2 Thin Films with Abnormally High Dielectric Permittivity for Memory and Logic Devices

Comparative Study of Pulsed Laser Deposited HfO 2 and Hf–aluminate Films for High- K Gate Dielectric Applications

Fabrication and characterization of La-doped HfO2 gate dielectrics by metal-organic chemical vapor deposition

Fabrication and Characterization of Zr-Rich Zr-Aluminate Films for High-Kappa Gate Dielectric Applications

Structure and Dielectric Properties of Ultra-Thin ZrO2 Films for High- K Gate Dielectric Application Prepared by Pulsed Laser Deposition

Advancements in Metal Oxide Thin Film Quality in Solution-Processed High-κ Dielectrics for High-Performance Transistors

Chemical Vapor Deposition Of Zrxhf1-Xo2 Thin Films Using Anhydrous Mixed-Metal Nitrates Precursors

Pulsed Laser Deposition of Zirconium Silicate Thin Films As Candidate Gate Dielectrics

Electrical and Reliability Characteristics of High-Κ HfO 2 Gate Dielectrics

Sub-0.5 nm equivalent oxide thickness scaling for Si-doped Zr1-xHfxO2 thin film without using noble metal electrode

Stabilization of Tetragonal Phase in Hafnium Zirconium Oxide by Cation Doping for High-K Dielectric Insulators

Ferroelectricity in dopant-free HfO2 thin films prepared by pulsed laser deposition

Structure and dielectric properties of Zr-Al-O thin films prepared by pulsed laser deposition