Abstract:Pressurization systems for propellant tanks of launch vehicles (LVs) with a liquid rocket engine are complex LV systems to provide cavitation-free operation of pumps and constant pressure in the gas cushion of the fuel tanks at constant consumption of liquid components of rocket propellant. There were already studies on the influence of the pressurant type on the heat and mass transfer in the LV propellant tank. The simulation was performed for a ground experiment with liquid nitrogen with helium gas and nitrogen gas used as the pressurant. In this work, experimental studies were performed on the dynamics of evaporation and condensation, changes in the pressure in the gas cushion, as well as changes in the mass of liquid nitrogen with the vessel pressurized with helium, nitrogen, and their mixtures with molar content of nitrogen of 23.2 mol. % and 52.2 mol. % and filled with liquid nitrogen to 30–70%. The experiments were conducted in a cylindrical vessel with height of 650 mm and internal diameter of 213 mm, pressurized to pressure of 0.3 MPa. The experiments resulted in dependences of variation of the pressure in the vessel and the mass of liquid nitrogen in the vessel at the stage of pressurization with a nitrogen-helium mixture of various concentrations at different levels of initial filling of the vessel with liquid nitrogen. The dependences of temperature changes in the liquid and vapor phases at eight different levels in the vessel height (50–600 mm) were obtained. During condensation, at the pressurization stage, and immediately after the end of pressurization, the surface layer of the liquid (about 10 mm) was observed to warm to a temperature close to the saturation point corresponding to the pressure in the vessel. The formation of this layer leads to cessation of condensation, cessation of pressure drop in the vessel, and beginning of evaporation due to external heat inflows. When the vessel is half filled with the liquid, loss of stability of the heated near-surface layer of liquid is observed because of the formation of large-scale convective flows. The destruction of the heated surface layer and its cooling to the temperature of the core of liquid, which is significantly subcooled, results in abrupt intensification of the condensation of the nitrogen vapor and significant decrease in the pressure in the vessel to a pressure equilibrium with the temperature of the liquid core.

A Physical and Mathematical Model of the Pressure Dynamics of Residue Gas inside a Nonpressurized Instrument Compartment of a High-Orbital Spacecraft

Development of a Simple Model for Predicting the Spark-Induced Bubble Behavior under Different Ambient Pressures

Investigation on Thermal Behavior During Pressurization Discharge of Liquid Oxygen under Different Acceleration Levels

Dynamic modeling, simulation and experimental investigation on cryogenic tank pressurization system

Appropriate Formulations for Velocity and Pressure Calculations at Gas-liquid Interface with Collocated Variable Arrangement

Numerical Simulation of Liquefied Gas Self-Pressurization for Small Spacecraft Propulsion Systems

A method for verifying the model of tank operational pressurization process during development of propellant supply system in liquid rocket engines of launch vehicle propulsion systems

Numerical simulation of gas leakage in manned spacecraft cabin

Estimation of Discharge Coefficient of Compartment Venting during Atmospheric Reentry of the Space Capsule

Effects of neutral gas pressure on calibration parameters of resistive bolometer sensors in fusion devices

Modeling of the Gas Dynamic Processes with Different Equations of State

Numerical and experimental study of the explosions caused by residual pressure in quick actuating vessels

Dynamic Analysis of the Cabin Atmosphere in a Manned Spacecraft

Developing Methods for Calculating Gas-Dynamic Parameters in Launch Canister During the Missile Launch

Nonequilibrium Ablation of Phenolic Impregnated Carbon Ablator

Physical Mechanisms Leading to Large Unsteady Pressure Fluctuations in a Gas Turbine Testing Facility

Experimental and Numerical Investigation of Stratification and Self pressurization in a High Pressure Liquid Nitrogen Storage Tank

Dynamics of Condensation and Evaporation of Liquid Nitrogen in a Closed Vessel Pressurized with Helium, Nitrogen, and Their Mixture

Numerical Simulation on Interface Evolution and Pressurization Behaviors in Cryogenic Propellant Tank on Orbit

Thermodynamic Analysis of Partially Filled Hydrogen Tanks in a Wide Scale Range

High Voltage Breakdown Induced by Outgassing of Space Materials