Abstract:Radiative properties are critical to quantify radiative energy fluxes between surfaces and in participating media. However, there is limited experimental data on temperature-dependent radiative properties of materials. This work focuses on experimentally measuring temperature-dependent diffuse reflectance in the near- and mid-infrared spectra (1–20 μm) for ceramic particles with applications as heat-transfer and thermal-storage media in concentrated solar power (CSP) plants. Specifically, a commercially available sintered bauxite proppant, ACCUCAST ID80, and its primary chemical constituents—alumina (Al2O3) and silica (SiO2)—are measured in powder form using a Fourier transform infrared spectrometer (FTIR) coupled with a specialized diffuse reflectance accessory and a heated stage. Room-temperature diffuse reflectance measurements show increased absorption in tests with greater mass fractions of the ceramic samples. There is a strong correlation in the measured reflectance spectra of ACCUCAST with alumina and silica in the spectral range 2000–500 cm−1 (5–20 μm). Whereas, for shorter wavelengths (<5μm), the absorptance for ACCUCAST is greater than the absorptance for alumina and silica, indicating contributions from other chemical species present in the composite material. For the first time, temperature-dependent diffuse reflectance measurements are reported for ACCUCAST up to 1000 °C. These results are compared against those of alumina and silica through the calculation of a thermal emittance. All three materials exhibit a calculated emittance of ∼0.9 at room temperature. However, this value decreases to ∼0.6 for ACCUCAST and drops to less than 0.4 for alumina and silica at 1000 °C. Thermal cycling in air at 1000 °C resulted in a visible color change from dark grey to light orange for ACCUCAST and a subsequent larger increase in reflectance for wavelengths less than 5 μm as compared to ACCUCAST thermally cycled at 1000 °C in vacuum. Alumina and silica spectra proved to be largely unaffected by thermal cycling under atmospheric conditions. Overall, this study establishes a powerful technique for the characterization of radiative properties of particulate materials as a function of temperature and presents a detailed case study of ACCUCAST, a candidate for next-generation particle-based CSP.

Spectral emissivity properties of reflective coatings

Method for emissivity measurement of semitransparent coatings at ambient temperature

Spectral emittance measurements of micro/nanostructures in energy conversion: a review

New experimental device for high-temperature normal spectral emissivity measurements of coatings

The Research for Heat Insulation Property of Architectural Reflective Thermal Insulating Coatings

Temperature-dependent diffuse reflectance measurements of ceramic powders in the near- and mid-infrared spectra

Infrared thermographic measurement of the surface temperature and emissivity of glossy materials

First spectral emissivity study of a solar selective coating in the 150 to 600 C temperature range

Study on Preparation and Properties of Infrared Radiant Coatings with High Emissivity

Study on Method for Measuring Coating Emissivity by Applying Active Irradiation Based on Infrared Thermal Imager

Experimental study on radiative properties of air plasma sprayed thermal barrier coatings

Theoretical investigation on spectral emissivity of thermal control coatings with optical-rough surface

Experimental Study Of Wide-Range Spectral Radiation Properties Of Air Plasma Sprayed Thermal Barrier Coatings

Thermal Emissivity Measurement with Two-temperature Method

Non-selective Reference Surfaces for Hyperspectral Remote Sensing in the Long-Wave Infrared Range

Measuring spectral emissivity up to 4000 K

Spectral, Directional Emittance at Elevated Temperatures for Various Materials

Differences in heat losses between glazing of various emissivities related to night sky radiation: Experimental and numerical analysis

Infrared emissivity measurement methods considering target reflective characteristics

Variable Emissivity Materials for Thermal Radiators: Methods for Characterizing Thermochromic Infrared Surfaces

Test of Solar Radiation Absorbing Coefficient