Abstract:A series of efficient adsorbents were prepared by a wet-impregnation method for CO2 separation from simulated biogas. A type of commercially available silica, named as FNG-II silica (FS), was selected as supports. FS was modified with a mixture of polyethyleneimine (PEI) and ethanolamine (MEA) to improve the initial CO2 adsorption capacity and thermal stability of the adsorbents. The influence of different adsorbents on CO2 adsorption performance was investigated by breakthrough experiments. Scanning electron microscopy (SEM), fourier transform infrared spectroscopy (FTIR), and N2 adsorption-desorption isotherm were used to characterize the silica before and after impregnating amine. Additionally, the thermal stability of adsorbents was measured by differential thermal analysis (TDA). Silica impregnated with mixtures of MEA and PEI showed increased CO2 adsorption performance and high thermal stability compared with those obtained from silica impregnated solely with MEA or PEI. With a simulated biogas flow rate of 100 mL/min at 0.2 MPa and 25 °C, FS-10%MEA-10%PEI exhibited a CO2 adsorption capacity of ca. 64.68 mg/g which increased by 81 % in comparison to FS-20%PEI. The thermal stability of FS-10%MEA-10%PEI was evidently higher than that of FS-20%MEA, and a further improvement of thermal stability was achieved with the increasing value of PEI/MEA weight ratio. It was showed that MEA was able to impose a synergistic effect on the dispersion of PEI in the support, reduce the CO2 diffusion resistance and thus increase CO2 adsorption performance. Additionally, if the total percentage of amine was the same, FS impregnated by different ratios of PEI to MEA did not exhibit an obvious difference in CO2 adsorption performance. FS-15%PEI-5%MEA could be regenerated under mild conditions without obvious loss of CO2 adsorption activity.

Adsorption Separation of CO2/CH4 from Landfill Gas by Ethanolamine-Modified Silica Gel

Enhanced Adsorption of Carbon Dioxide from Simulated Biogas on PEI/MEA-Functionalized Silica

Adsorption separation of carbon dioxide, methane and nitrogen on monoethanol amine modified β-zeolite

CO2 Adsorption by Polyamine-Based Protic Ionic Liquid-Functionalized Mesoporous Silica: Regenerability and Influence of Flue Gas Contaminants

Adsorption separation of CO_2 from flue gas by hyperbranched solid-amine

Effects of Alkyl Groups on Monoethanolamine Derivatives for Biomethane from Biogas Upgrading

Utilizing silica fume and synthetically produced mesoporous silicas for simulated flue gas CO2 adsorption

Investigation of highly efficient adsorbent based on Ni-MOF-74 in the separation of CO2 from natural gas

CO2/CH4 Separation Performance of SiO2/PES Composite Membrane Prepared by Gas Phase Hydrolysis and Grafting Coating in Gas-Liquid Membrane Contactor: A Comparative Study

The Influence of Pore Size and Pore Structure of Silica-Based Material on the Amine-Modified Adsorbent for CO2 Capture

Experimental, economic, and life cycle carbon footprint assessment of low‐cost adsorbents for siloxane removal from landfill gas

Modified mesoporous silica derived from bamboo leaf using cetyltrimethylammonium bromide and 3-aminopropyl triethoxysilane as CO2 adsorbent in biogas purification

Effects of hydroxyethyl group on monoethanolamine (MEA) derivatives for biomethane from biogas upgrading

Facile fabrication of mesoporosity silica as support for solid amine CO2 adsorbents with enhanced adsorption capacity and kinetics

CO2 separation from flue gases by polypropylene hollow fiber membrane contactor

Experimental investigation of CO2 separation by adsorption methods in natural gas purification

A Hybrid Method Combining Membrane Separation and Chemical Absorption for Flexible CH 4 Refinement and CO 2 Separation in Natural Gas

Structural Modulation of UiO-66-NH2 Metal-Organic Framework Via Interligands Cross-Linking: Cooperative Effects of Pore Diameter and Amide Group on Selective CO2 Separation

Novel Monoethanolamine Absorption Using Ionic Liquids As Phase Splitter for CO2 Capture in Biogas Upgrading: High CH4 Purity and Low Energy Consumption

Breakthrough analysis on selective adsorption of CO2 from biogas by polyethylenimine-impregnated resins

A surfactant modified solid amine adsorbent to enhance CO 2 adsorption performance