Abstract:Tyre Derived Aggregates (TDA), produced by shredding scrap car tyres, show many interesting features, such as: durability, low bulk density, thermal insulation, good drainage properties or ability to damp vibrations, which makes them a useful material for civil engineering. One of the possible applications is the partial filling of excavations with TDA during the construction of underground pipelines in order to decrease the load applied on the pipe. The article presents results of a multivariate numerical study of 2D FEM models of a flexible PVC pipe - soil system, in which the presence of a mixture of sand and TDA (tyre chips - 40% by weight) (STCh) in the backfill was simulated. The models differed in the thickness of the STCh layer ( t = 0 – 0.9 m) and inclination of the excavation walls (a trench with vertical walls or open excavations with 3:1 and 1:1 slopes). The main goal of the numerical analyses, performed by means of the Z_Soil.PC program, were to investigate the effect of the presence of the softer STCh layer in the backfill zone on the pipe deformation (relative deflection δ / D ) and internal forces in the pipe wall. The soil was simulated with the use of either the Hardening Soil Small (HSS) or Coulomb-Mohr (CM) constitutive model with the parameters' values estimated based on results of laboratory tests (published by researchers from Wollongong University). The PVC pipe was modelled as linear elastic. The results of the analyses show that, due to enhanced arching, STCh layer of the optimum thickness t = 0.55 m can effectively reduce δ / D when used in the backfill of the trench. It can also decrease the difference between the maximum and minimum bending moment in the pipe wall, leading to less ovalization of the pipe cross-section. This positive effect diminishes if the width of excavation is larger, as the model is gradually transforming towards the positive projecting conduit type. The CM model gives underestimated values of the pipe deformation and internal forces. Though, in the case of lack of all the HSS parameters' values, it is better to use the CM model with E = E 50 than E = E ur as it gives a better approximation of pipe behaviour.

Usage of Tyre Derived Aggregates as backfill around buried pipelines crossing strike-slip faults; model tests

A Simplified Analytical Solution of Pipeline Response under Normal Faulting

Tunnelling-induced response of buried pipelines and their effects on ground settlements

An analytical solution for landslide impact on buried continuous pipelines

Instability Mechanism of Shallow Tunnel in Soft Rock Subjected to Surcharge Loads

Numerical Study of the Use of Tyre-Derived-Aggregate (TDA) as the Backfill Above Flexible PVC Pipeline

Numerical Analysis of the Effect of Tunnel Excavation on Underground Pipelines

Earthquake damage mitigation methods for buried pipelines under compressive loads: A case study of the Thames water pipeline

Experimental and Numerical Studies on Mechanical Behavior of Buried Pipelines Crossing Faults

Response of Pipelines under Fault Crossing

Mechanical Behavior of Submarine Pipelines under Active Strike-Slip Fault Movement

Vertical Displacement of Underground Pipeline Caused by Shield Tunnel Crossing in Pasternak Foundation

Analytical Solution for Upheaval Buckling of Shallow Buried Pipelines in Inclined Cohesionless Soil

Research on the interaction between trench material and pipeline under fault displacement

Reliability analysis of large-diameter high-grade-steel natural gas pipelines under fault action

Parametric Study on the Trench Designing for X80 Buried Steel Pipeline Crossing Oblique-Reverse Fault

Mechanical Behavior of Polyethylene Pipes under Strike-Slip Fault Movements

Analysis of influence of ground penetrating shield tunnel excavation on adjacent underground pipeline

Modelling and Analysing Failure Modes of Buried Pipelines Perpendicularly Crossing Landslide Boundaries

Using Finite Element Method for Stress-Strain Evaluation of Commonly Used Buried Pipelines in Fault

Centrifuge and numerical modeling of brittle damage of buried pipelines subjected to tunneling induced ground settlements