Abstract:Miniaturization of gas chromatography (GC) instrumentation is of interest because it addresses current and future issues relating to compactness, portability and field application. While incremental advancements continue to be reported in GC with columns fabricated in microchips (referred to in this paper as "microchip columns"), the current performance is far from acceptable. This lower performance compared to conventional GC is due to factors such as pooling of the stationary phase in corners of non-cylindrical channels, adsorption of sensitive compounds on incompletely deactivated surfaces, shorter column lengths and less than optimum interfacing to injector and detector. In this work, a GC system utilizing microchip columns was developed that solves the latter challenge, i.e., microchip interfacing to injector and detector. A microchip compression clamp was constructed to heat the microchip (i.e., primary heater), and seal the injector and detector fused silica interface tubing to the inlet and outlet ports of the microchip channels with minimum extra-column dead volume. This clamp allowed occasional operation up to 375°C and routine operation up to 300°C. The compression clamp was constructed of a low expansion alloy, Kovar™, to minimize leaking due to thermal expansion mismatch at the interface during repeated thermal cycling, and it was tested over several months for more than one hundred injections without forming leaks. A 5.9m long microcolumn with rectangular cross section of 158μm×80μm, which approximately matches a 100μm i.d. cylindrical fused silica column, was fabricated in a silicon wafer using deep reactive ion etching (DRIE) and high temperature fusion bonding; finally, the channel was coated statically with a 1% vinyl, 5% phenyl, 94% methylpolysiloxane stationary phase. High temperature separations of C10-C40 n-alkanes and a commercial diesel sample were demonstrated using the system under both temperature programmed GC (TPGC) and thermal gradient GC (TGGC) conditions. TGGC analysis of a complex essential oil sample was also demonstrated. Addition of a secondary heater and polyimide insulation proved to be helpful in achieving the desired elution temperature without having to raise the primary heater temperature above 300°C for high boiling point compounds.

High-performance MEMS-based gas chromatography column with integrated micro heater

Extending the upper temperature range of gas chromatography with all-silicon microchip columns using a heater/clamp assembly

The Design of Resistive-Heating System for Capillary Column

A microchip gas chromatography column assembly with a 3D metal printing micro column oven and a flexible stainless-steel column

Separation characteristics of an integrated temperature-controlled micro gas chromatography chip

Microchip Gas Chromatography Column Using Magnetic Beads Coated with Polydimethylsiloxane and Metal Organic Frameworks

Chopper-modulated gas chromatography electroantennography enabled using high-temperature MEMS flow control device

Microfluidic integration of μPID on μcolumn for ultracompact micro-gas chromatography

Microfabricated planar glass gas chromatography with photoionization detection

MEMS-based Sensing Technology for the Gas Chromatograph Analysis

A Portable Micro-Gas Chromatography with Integrated Photonic Crystal Slab Sensors on Chip

Design, Fabrication, and Evaluation of Microfabricated Columns for Gas Chromatography

Non-Silicon MEMS Calorimetric Gas Flow Sensor

Fabrication of micro-gas chromatograph columns for fast chromatography

An all-glass based micro gas chromatographic column for light hydrocarbon separation with HKUST-1 as stationary phase

A fully electronic microfabricated gas chromatograph with complementary capacitive detectors for indoor pollutants

Gas Analysis System on Chip With Integrated Diverse Nanomaterial Sensor Array

A MEMS-enabled portable gas chromatography injection system for trace analysis

A Graphitized-Carbon Monolithic Column

High-Sensitivity Micro-Gas Chromatograph–Photoionization Detector for Trace Vapor Detection

A Portable Micro Gas Chromatography System for Lung Cancer Associated Volatile Organic Compound Detection