Abstract:The microstructure evolution of Ni-based superalloys during heat treatment is of great significance for obtaining better service performance. However, heat treatment experimentation is costly and time-consuming, and sometimes fails to reveal physical mechanisms well. In the present study, a multiphase-field model coupled with an explicit nucleation algorithm was established to simulate the precipitation and growth of γ′ phase in DD6 superalloy, which can be applied to a multicomponent elastic-inhomogeneous system. The PanNickel© database was used to calculate thermodynamic and kinetic data in multicomponent superalloys. First, the coupling method of multiphase-field model and explicit nucleation algorithm was introduced. The coupled model was used to simulate the precipitation of γ′ phase under isothermal and non-isothermal conditions. It was found that a unimodal microstructure was formed under isothermal conditions and there was a “soft impingement” phenomenon, while a bimodal distribution composed of cuboidal γ′ precipitates and fine secondary γ′ precipitates was formed during a cooling process of 25–125 °C/min. The effect of cooling rate was studied. Then, the chemical and elastic driving forces were analyzed. It was found that Al and Ta contributed most to the chemical driving force, while Re and W gathered at the γ/γ′ interface and inhibited the growth of γ′ phase. γ′ precipitates had a cuboidal shape under the influence of elastic driving force. Finally, the growth and coarsening process of γ′ phase was studied and compared with the well-known Lifshitz−Slyosov−Wagner (LSW) theory. The growth of γ′ phase can be divided into rapid growth, coarsening and quasi-static coarsening stages according to the simulation results, among which the coarsening stage is basically consistent with the LSW theory. The current model can be used to simulate the precipitation and growth of single crystal superalloys where multicomponent and elastic effects are considered.

Multi-phase-field simulation of D019-χ transformation in Co-Al-W superalloy with L12-γ′ + fcc-γ phases

Phase-field simulation of γʹ coarsening behavior in cobalt-based superalloy

Phase-field simulation of early-stage kinetics evolution of γ' phase in medium supersaturation Co-Al-W alloy

Precipitation kinetics and morphology evolution of the Co3(Al, W) phase in a medium supersaturation Co–Al–W alloy

Microstructures and Mechanical Properties of a L12-structured Precipitation Strengthened Co-based Superalloy

Multi-component Phase-Field Simulation of Microstructural Evolution and Elemental Distribution in Fe–Cu–Mn–Ni–Al Alloy

Multi-phase Field Simulation of Multi-Grain Peritectic Transition in Multiple Phase Transformation

Phase Characterization and Formation Behavior in 6 Wt% Si High-silicon Austenitic Stainless Steel During Isothermal Aging

Phase-field simulation of γ' precipitates rafting and creep property of Co-base superalloys

Segregation-assisted phase transformation and anti-phase boundary formation during creep of a γ′-strengthened Co-based superalloy at high temperatures

Crystal plasticity phase-field simulation of rafting and creep properties with a continuous change of the mismatch strain in a Co-Al-W superalloy

Crystal plasticity phase-field simulation of creep property of Co-base single crystal superalloy with pre-rafting

Precipitation and Growth Simulation of Γ′ Phase in Single Crystal Superalloy DD6 with Multiphase-Field Method and Explicit Nucleation Algorithm

Cascading phase transformations in situ for the simulated coarse-grained heat-affected zone of P92 heat-resistant steel

Stress-induced influence on the evolution of γ′ phase in dendritic area during long-term stress aging at 900 °C in Ni-based superalloy K444

Microstructures and Mechanical Properties of a L1 2 -structured precipitation Strengthened Co-based Superalloy

Phases, microstructure and mechanical properties of Al x CoCrFeNi high-entropy alloys at elevated temperatures

Microstructure and Creep Performance of a Multicomponent Co-Based L1 2-Ordered Intermetallic Alloy

Low cycle fatigue of a γ'-strengthened Co-based single crystal superalloy at 900 °C

Crystal plasticity phase-field simulation of slip system anisotropy during creep of Co-Al-V monocrystal alloy under multidirectional strain

Thermodynamic Stability of Co-Al-W L12 γ'