Abstract:Nanofiber catalysts are potentially promising to be equipped in the lean-burned vehicle exhaust emission system considering its facile synthesis, low-cost, long durability in contrast to the traditionally complicated powder based catalyst. Here, via electrospinning method, we synthesized YMn2O5 nanofibers (average diameter (similar to)93 nm) including nanowire stacked with particles, and hollow tubes with or without inside nanowires. The morphologies remained even after hydrothermal aging at 800 degrees C for 10 h with 10% H2O stream. X-ray photoelectron spectrum revealed Mn4+/Mn3+ ratio 0.589 on the surface of YMn2O5 catalyst (YMO), indicating the existence of oxygen vacancies. The highest conversion of electrospun mullite fibers at 310 degrees C is (similar to)18% higher than powder based YMO at 352 degrees C in the presence of 5% H2O at WHSV = 240,000 ml g(-1) h(-1). The extracted activation energy from NO-to-NO2 conversion curves of YMO nanofiber (61.68 kJ/mol) is slightly lower than that of powder-based mullite (91.45 kJ/mol), consistent with calculated 68.16 kJ/mol on the fiber YMO surface (121) with a rate-limiting step of the NO2 desorption. The catalytic activity can be attributed to the unit occupy of the e(g) (d(z)(2) and d(x-y)(2 2)) orbitals of Mn-dimer atoms around fermi level based on the combination of the theoretical calculations and DRIFTS spectra analysis. Importantly, after the hash hydrothermal-aging, the highest NO oxidation conversion of powder-based mullite is less than 50%, while the fiber maintains a conversion of 62%. Moreover, the fresh YMO fiber maintained superior oxidation stability for 12 h at its maximum conversion of 66%. This work provides the possibility for mullite oxide fibers to replace powder-based precious metal catalyst coating on monolith converter.

Monodisperse Sr-La2O3 hybrid nanofibers for oxidative coupling of methane to synthesize C2 hydrocarbons.

Morphology Effects of Nanoscale Er2O3 and Sr-Er2O3 Catalysts for Oxidative Coupling of Methane

Oxidative Coupling of Methane over Y2O3 and Sr–Y2O3 Nanorods

Facile Synthesis of Mn-Fe/CeO2 Nanotubes by Gradient Electrospinning and Their Excellent Catalytic Performance for Propane and Methane Oxidation.

Oxidative Coupling of Methane by Nanofiber Catalysts

Nanosheet-Like Ho2O3 and Sr-Ho2O3 Catalysts for Oxidative Coupling of Methane

Simple synthesis of ultrasmall β-Mo<sub>2</sub>C and α-MoC<sub>1−x</sub> nanoparticles and new insights into their catalytic mechanisms for dry reforming of methane

Characterization of Nanosized SrTiO_3 Catalyst for Oxidative Coupling of Methane by in Situ ESR and TPSR

Metal Ions (Li, Mg, Zn, Ce) Doped into La2O3 Nanorod for Boosting Catalytic Oxidative Coupling of Methane

Fast Optimization of Limgmnox/La2o3 Catalysts for the Oxidative Coupling of Methane

In Situ ESR and TPSR Measurements of SrTi0.975Li0.025O3-δ Nanocatalysts for Oxidative Coupling of Methane at Low Temperature

Enhanced Catalytic Activity of Α-Fe2o3 Nanorods Enclosed with {110} and {001} Planes for Methane Combustion and CO Oxidation

Highly Active and Stable Lanthanum‐doped Core–Shell‐structured Ni@SiO2 Catalysts for the Partial Oxidation of Methane to Syngas

Electrospun YMn2O5 Nanofibers: A Highly Catalytic Activity for NO Oxidation

Morphology-Controlled Construction and Aerobic Oxidative Desulfurization of Hierarchical Hollow Co–Ni–Mo–O Mixed Metal-Oxide Nanotubes

Lithium carbonate-promoted mixed rare earth oxides as a generalized strategy for oxidative coupling of methane with exceptional yields

Selective electrochemical oxidative coupling of methane mediated by Sr2Fe1.5Mo0.5O6-δ and its chemical stability

Synthesis and characterization of the flower-like La Ce1−O1.5+ catalyst for low-temperature oxidative coupling of methane

In-depth understanding of the crystal-facet effect of La2O2CO3 for low-temperature oxidative coupling of methane

Enhancing electrochemical methane coupling in solid oxide cells by tuning oxygen species in the catalyst

Nanocatalysts Anchored on Nanofiber Support for High Syngas Production Via Methane Partial Oxidation