Abstract:To prevent primary water stress corrosion cracking (PWSCC), water jet peening (WJP) has been used on the welds of Ni-based alloys in pressurized water reactors (PWRs). Before WJP, the welds are machined and buffed in order to conduct a penetrant test (PT) to verify the weld qualities to access, and microstructure evolution takes place in the target area due to the severe plastic deformation. The compressive residual stresses induced by WJP might be unstable under elevated temperatures because of the high dislocation density in the compressive stress layer. Therefore, the stability of the compressive residual stresses caused by WJP was investigated during long-term operation by considering the microstructure evolution due to the working processes. The following conclusions were made: The compressive residual stresses were slightly relaxed in the surface layers of the thermally aged specimens. There were no differences in the magnitude of the relaxation based on temperature or time. The compressive residual stresses induced by WJP were confirmed to remain stable under elevated temperatures. The stress relaxation at the surface followed the Johnson-Mehl equation, which states that stress relaxation can occur due to the recovery of severe plastic strain, since the estimated activation energy agrees very well with the self-diffusion energy for Ni. By utilizing the additivity rule, it was indicated that stress relaxation due to recovery is completed during the startup process. It was proposed that the long-term stability of WJP under elevated temperatures must be assessed based on compressive stresses with respect to the yield stress. Thermal elastic-plastic creep analysis was performed to predict the effect of creep strain. After 100 yr of simulated continuous operation at 80% capacity, there was little change in the WJP compressive stresses under an actual operating temperature of 623 K. Therefore, the long-term stability of WJP during actual operation was analytically predicted.

Nitrogen-based Pressure Stabilization and Its Effectiveness of the Makeup Water System of a Hot Water Boiler

The Experimental Study on Different Ratios of Vortex Tube Hot End Pressure and Cold End Pressure

Regulation of the Output Temperature in a Novel Water Heating System Using Solid Graphite As Sensible Heat Thermal Energy Storage Medium: Effects of Water Tank

THE EXPERIMENTAL INVESTIGATION OF STEAM CONDENSATION WITH NON-CONDENSABLE GAS UNDER NATURAL CONVECTION

Numerical Study Of The Gas-Steam Transient Behavior In The Integrated Pressurizer

Application of Multi-Tangential Firing Technology to Settling the High Temperature Corrosion of Water Wall Tube of Boiler

THE EFFECTS OF A NON-CONDENSABLE GAS ON PRESSURIZER INSURGE TRANSIENTS UNDER THE HIGH PRESSURE

Advances in Stability of Anaerobic Bioreactor Lashed by Environmental and Wastewater Composition Variations

Analysis of the influence of combustion air humidification technology on low nitrogen combustion law of the gas boiler

Sufficient Conditions for Globally Asymptotic Self-Stability of Pressurized Water Reactors

Long-Term Stability of Residual Stress Improvement by Water Jet Peening Considering Working Processes

Experimental Investigation on the Pressure Response Characteristic of the Gravity Driven Boron Injection System / Experimentelle Untersuchung Zur Druckantwortcharakteristik Eines Gravitationsgetriebenen Boreinspeisesystems

Experimental Study on Influence of Gas Space on Two-Phase Flow Stability

The Investigation on Heat Transfer Characteristics of Steam Condensation in Presence of Noncondensable Gas under Natural Convection

Experimental investigation on the pressure response characteristic of the gravity driven boron injection system

Analysis of the Structure Stability of the Hot Gas Tube in HTR-PM

Overall pressure balance and system stability in a liquid–solid circulating fluidized bed

Effect of heat flux on the stability of two phase flow natural circulation with low steam quality

Self-Stability Analysis And Nonlinear Power-Level Control For Pressurized Water Reactors

Influence mechanism of gas space on natural circulation two-phase flow stability

Experimental Study of the Processes of Gas-Steam Pressurizer Insurge Transients