Abstract:Clarifying the deformation behaviors of microstructures could greatly help us understand the precipitation-strengthening mechanism in alloys. However, it is still a formidable challenge to study the slow plastic deformation of alloys at the atomic scale. In this work, the phase-field crystal method was used to investigate the interactions between precipitates, grain boundary, and dislocation during the deformation processes at different degrees of lattice misfits and strain rates. The results demonstrate that the pinning effect of precipitates becomes increasingly strong with the increase of lattice misfit at relatively slow deformation with a strain rate of 10-4. The cut regimen prevails under the interaction between coherent precipitates and dislocations. In the case of a large lattice misfit of 19.3%, the dislocations tend to move toward the incoherent phase interface and are absorbed. The deformation behavior of the precipitate-matrix phase interface was also investigated. Collaborative deformation is observed in coherent and semi-coherent interfaces, while incoherent precipitate deforms independently of the matrix grains. The faster deformations (strain rate is 10-2) with different lattice misfits all are characterized by the generation of a large number of dislocations and vacancies. The results contribute to important insights into the fundamental issue about how the microstructures of precipitation-strengthening alloys deform collaboratively or independently under different lattice misfits and deformation rates.

Atomic Insight into the Shearing Behavior of Precipitates in an Al-Cu-Mg-Ag Alloy

Shearing and rotation of β″ and βʹ precipitates in an Al-Mg-Si alloy under tensile deformation: In-situ and ex-situ studies

Reshaping Precipitate Structure and Morphology in an Al-Zn-Mg-Cu Alloy Through Dislocation-Precipitate Interactions

Subtle Atomistic Processes of S-phase Formation in Al-Cu-Mg Alloys

Quantitative Transmission Electron Microscopy and Atom Probe Tomography Study of Ag-dependent Precipitation of Ω Phase in Al-Cu-Mg Alloys

Shear strength of Al–Cu alloy with different types of hardening precipitates: molecular dynamics and continuum modeling

The Structural and Compositional Evolution of Precipitates in Al-Mg-Si-Cu Alloy

Dislocation dynamics prediction of the strength of Al-Cu alloys containing shearable $θ''$ precipitates

Discrete dislocation dynamics simulations of dislocation-$θ'$ precipitate interaction in Al-Cu alloys

An Atomic-Resolution Investigation of Precipitation Evolution in Al-Mg-Ag Alloys

Atomic-Scale Insights into the Deformation Mechanism of the Microstructures in Precipitation-Strengthening Alloys

Heterogeneous nucleation of T1 precipitates in solid solution of Al-Cu-Li alloys from Ag-rich structures: An ab initio study

In-situ TEM study of the dynamic interactions between dislocations and precipitates in a Cu-Cr-Zr alloy

Insights into precipitation characteristics and strengthening mechanisms in a low Cu/Mg ratio Al-Cu-Mg-Ag alloy

Combined electron beam imaging and ab initio modeling of T1 precipitates in Al–Li–Cu alloys

Study on the Strengthening Mechanism of Al-Cu-Mg-Ag Alloy with the Valence Electron Structures and Atomic Bonding of Precipitates

On the Shear Strain Associated with T1 Precipitation in Al-Cu-Li(-Mg-Ag) Alloys

Fine precipitation scenarios of AlZnMg(Cu) alloys revealed by advanced atomic-resolution electron microscopy study Part I: Structure determination of the precipitates in AlZnMg(Cu) alloys

Quantitative Analysis of Precipitation in an Al–Zn–Mg–Cu–Li Alloy

Atomic-scale Investigation on the Evolution of T1 Precipitates in an Aged Al-Cu-Li-Mg-Ag Alloy

The Interaction Mechanisms Between Dislocations and Nano-Precipitates in CuFe Alloys: a Molecular Dynamic Simulation