Abstract:The cryptomelane-type manganese oxide (OMS-2)-supported Co (xCo/OMS-2; x = 5, 10, and 15 wt.%) catalysts were prepared via a pre-incorporation route. The as-prepared materials were used as catalysts for catalytic oxidation of toluene (2000 ppmV). Physical and chemical properties of the catalysts were measured using the X-ray diffraction (XRD), Fourier transform infrared spectroscopic (FT-IR), scanning electron microscopic (SEM), X-ray photoelectron spectroscopy (XPS), and hydrogen temperature-programmed reduction (H2-TPR) techniques. Among all of the catalysts, 10Co/OMS-2 performed the best, with the T90%, specific reaction rate at 245°C, and turnover frequency at 245°C (TOFCo) being 245°C, 1.23 × 10-3 moltoluene/(gcat·sec), and 11.58 × 10-3 sec-1 for toluene oxidation at a space velocity of 60,000 mL/(g·hr), respectively. The excellent catalytic performance of 10Co/OMS-2 were due to more oxygen vacancies, enhanced redox ability and oxygen mobility, and strong synergistic effect between Co species and OMS-2 support. Moreover, in the presence of poisoning gases CO2, SO2 or NH3, the activity of 10Co/OMS-2 decreased for the carbonate, sulfate and ammonia species covered the active sites and oxygen vacancies, respectively. After the activation treatment, the catalytic activity was partly recovered. The good low-temperature reducibility of 10Co/OMS-2 could also facilitate the redox process accompanied by the consecutive electron transfer between the adsorbed O2 and the cobalt or manganese ions. In the oxidation process of toluene, the benzoic and aldehydic intermediates were first generated, which were further oxidized to the benzoate intermediate that were eventually converted into H2O and CO2.

Performance of Co/MgO Catalyst for CO2 Reforming of Toluene As a Model Compound of Tar Derived from Biomass Gasification

Experimental study of Ni/MgO catalyst in carbon dioxide reforming of toluene, a model compound of tar from biomass gasification

Catalytic performance of Mn-promoted Ni/MgO catalysts in CO 2 reforming of toluene used as model compound of tar produced from biomass: Influence of preparation methods

Influence of Supports on Catalytic Behavior of Nickel Catalysts in Carbon Dioxide Reforming of Toluene As a Model Compound of Tar from Biomass Gasification.

Catalytic conversion of toluene as a biomass tar model compound using monolithic biochar-based catalysts decorated with carbon nanotubes and graphic carbon covered Co-Ni alloy nanoparticles

Catalytic Cracking and Catalyst Deactivation/regeneration Characteristics of Fe-loaded Biochar Catalysts for Tar Model Compound

Steam Reforming of Biomass Tar Model Compounds over Monolithic Catalysts

Preparation of highly dispersed lignite-char-supported cobalt catalyst for stably steam reforming of biomass tar at low temperature

Promote the Efficient Co-Combustion of Toluene & CO in Pt/CeO2 Catalyst: Orientally Adjusting the Oxidized SMSI to Optimize Acid Site and Oxygen Vacancy

The study of catalytic reforming of coke oven gas producing hydrogen-rich gas

The study of coke resistance of Ni/ZrO2 by core-shell structure coupling with cobalt doping modification in CO2 reforming of tar

Total Oxidation of Toluene and Propane over Supported Co3O4 Catalysts: Effect of Structure/Acidity of MWW Zeolite and Cobalt Loading.

Promotional effect of cobalt doping on catalytic performance of cryptomelane-type manganese oxide in toluene oxidation

Evaluation of Different Oxygen Carriers for Chemical Looping Reforming of Toluene as Tar Model Compound in Biomass Gasification Gas: A Thermodynamic Analysis

Catalytic ozone oxidation toluene over supported manganese cobalt composite: influence of catalyst support

Effect of Calcination Temperature on Characteristics and Performance of Ni/MgO Catalyst for CO2 Reforming of Toluene

Study of Partial Oxidation and CO2 Reforming of Methane on Co Based Catalysts

Monolithic biochar-supported cobalt-based catalysts with high-activity and superior-stability for biomass tar reforming

LaCoO3 is a promising catalyst for the dry reforming of benzene used as a surrogate of biomass tar

Catalytic Steam Reforming of Biomass Tar Model Compounds with Low Cost Catalysts: Effect of Operation Conditions

Highly active and stable cobalt catalysts with tungsten carbide-activated carbon support for dry reforming methane: Effect of the different promoters