Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

Experimental Investigation of the Instantaneous Mass Transfer Coefficient at Steam-Liquid Interface During Water Film Flash Evaporation in Closed Chamber

Experimental Study on Heat Transfer Characteristics of Flash Evaporation of Water Film in Open System

Experimental and numerical simulation study on the mass transfer characteristics of static flash evaporation

Experimental Study on Energy Transformation and Separation Characteristic of Circulatory Flash Evaporation

Experimental Study on Non-Equilibrium Characteristics of Circulatory Flash Evaporation

EXPERIMENTAL STUDY ON HEAT TRANSFER CHARACTERISTICS OF FLASH EVAPORATION IN CYCLE SYSTEM

Experimental Investigation on Some Key Variables During Pool Water Flash Evaporation

Experimental Study on Heat Transfer Characteristics of Circulatory Flash Evaporation

Experimental study on the interfacial wave and local heat transfer coefficient of stable steam jet condensation in a rectangular mix chamber

Droplet Evaporation to Boiling in Van Der Waals Fluid

Experimental Investigation of Capillary-Assisted Evaporation on the Outside Surface of Horizontal Tubes

Experimental Study on the Direct Contact Condensation of Steam Jet in Subcooled Water Flow in a Rectangular Mix Chamber

Experimental Study on Transient Heat/mass Transfer Characteristics During Static Flash of Aqueous NaCl Solution

Study on Steam-Carrying Effect in Static Flash Evaporation

Experimental investigation on flashing duration time

The Effect of Interfacial Evaporation on Heat and Mass Transfer of Falling Liquid Film

Experimental Investigation on Thermal Characteristics of Spray Flash Evaporation under High Temperature and High Pressure

Mass transfer characteristics of the high temperature falling film evaporation over a vertical wall under countercurrent laminar airflow

Experimental and Numerical Investigations on Flash Evaporation of a Sessile Droplet under Reduced Pressure

Experimental Investigation of Dynamic Evaporation Characteristics of Liquid Droplet on Heated Surface

Experimental Study on Spray Flash Evaporation under High Temperature and Pressure