Thermodynamic Analysis for Synthesis of Dimethyl Ether and Methanol from Synthesis Gas

Zhang Hai

2001-01-01

Abstract:Thermodynamic analysis is carried out for the compound reaction system of diethyl ether and methanol from synthesis gas. The equilibrium composition and the selectivities in equilibrium are calculated for different initial compositions, temperature and pressure.

What problem does this paper attempt to address?

Thermodynamic Analysis for Direct Synthesis of Dimethyl Ether from CO And/or CO_2 Hydrogenation

Tiefeng Wang

2007-01-01

Abstract:Thermodynamic analysis was carried out for the reaction system of dimethyl ether synthesis by CO and/or CO2 hydrogenation.The equilibrium yields of dimethyl ether were calculated for different initial feed gas compositions,temperature and pressure.The results showed that the equilibrium yield of dimethyl ether decreased with the increase of temperature,and increased with the increase of pressure or CO/(CO+CO2) molar ratio.The thermodynamic data for methanol synthesis by CO/CO2 mixed gas hydrogenation were also calculated out for comparison.
Analysis of Chemical Equilibrium in Direct Synthesis of Dimethyl Ether from Syngas

王志良,王金福,刁杰,韩明汉,金涌

DOI: https://doi.org/10.3321/j.issn:1000-8144.2002.02.003

2002-01-01

Abstract:Chemical equilibrium in direct synthesis of dimethyl ether from syngas was calculated and analyzed by using an appropriate thermodynamic model.The effect of reaction temperature,pressure, n (H 2)/ n (CO+CO 2)ratio,carbon dioxide content and water content in reactant was investigated with thorough understanding of this reaction thermodynamics.
Thermodynamics of the Single-Step Synthesis of Dimethyl Ether from Syngas

王志良,王金福,任飞,韩明汉,金涌

2004-01-01

Tsinghua Science & Technology

Abstract:A detailed thermodynamic analysis of single-step synthesis of dimethyl ether (DME) from syngas has been performed. From experiments and theoretical calculations, a suitable thermodynamic model based on Reid's thermodynamic data and the Soave-Redlich-Kwong equation of state was determined. Using this model, a careful analysis of direct synthesis of dimethyl ether from syngas was carried out. Reaction synergy in the synthesis can greatly improve CO conversion and DME yield. Lower temperatures and higher pressures favor higher CO conversion and DME yield. Compared to methanol synthesis, however, the temperature has a smaller effect on the reaction. The direct synthesis of dimethyl ether can exploit CO-rich syngas efficiently due to the maximum DME yield obtained at H2/(CO+CO2) mole ratio =1. A small amount of CO2 in the reactant mixture has little effect on the reaction. Under conditions of H2/(CO+CO2) feedstock, water in the system can improve the reaction performance.
Equilibrium calculations for direct synthesis of dimethyl ether from syngas

Gholamreza Reza Moradi,Javad Ahmadpour,Fereydoon Yaripour,Jinfu Wang

DOI: https://doi.org/10.1002/cjce.20373

2011-01-01

Abstract:Thermodynamic analysis of single-step synthesis of dimethyl ether (DME) from syngas over a bi-functional catalyst (BFC) in a slurry bed reactor has been investigated as a function of temperature (200-240 degrees C), pressure (20-50 bar), and composition feed ratio (H-2/CO: 1-2). The BFC was prepared by physical mixing of CuO/ZnO/Al2O3 as a methanol synthesis catalyst and H-ZSM-5 as a methanol dehydration catalyst. The three reactions including methanol synthesis from CO and H-2, methanol dehydration to DME and water-gas shift reaction were chosen as the independent reactions. The equilibrium thermodynamic analysis includes a theoretical model predicting the behaviour and a comparison to experimental results. Theoretical model calculations of thermodynamic equilibrium constants of the reactions and equilibrium composition of all components at different reaction temperature, pressure, and H-2/CO ratio in feed are in good accordance with experimental values.
Research on a New 2-(2-Dimethylaminoethoxy) Ethanol Synthesizing Process

Ya-jing SHI,Xiao-ming YE,Qi ZHANG,Rui GAO,Chao QIAN,Xin-zhi CHEN

DOI: https://doi.org/10.3969/j.issn.1003-9015.2017.05.020

2017-01-01

Abstract:A new process for 2-(2-dimethylaminoethoxy) ethanol synthesis via reaction of ethylene oxide and dimethyl amine was developed, which also produced 2-dimethylaminoethanol as a byproduct. Effects of reaction temperature, reaction pressure, molar ratio of ethylene oxide to dimethyl amine and solvent on product distribution were studied. Under optimized conditions of n(C2H7N):n(C2H4O)=1:1~2, 80℃ and 1.2MPa, the conversion of dimethyl amine is over 95% and the conversion of ethylene oxide is over 80%. The weight ratio of 2-(2-dimethylaminoethoxy) ethanol to 2-dimethylaminoethanol is in the range of 0~4, which increases with the increase of molar ratio between ethylene oxide and dimethyl amine. Therefore, the product distribution can be controlled by changing molar ratio of reactants.
Thermodynamic Analysis of Dimethoxymethane Synthesis Reaction

Tiefeng Wang

2013-01-01

Abstract:The standard enthalpy of formation,entropy and heat capacity of dimethoxymethane were calculated by using Benson group contribution method.The mole enthalpy changes,the Gibbs free energies and the equilibrium constants of the reaction of dimethoxymethane synthesis from methanol and formaldehyde were calculated as a function of temperature.The liquid activity coefficients of formaldehyde-methanol-water-dimethoxymethane system were predicted with UNIFAC group contribution model.The effects of temperature and the formaldehyde/methanol mole ratio on formaldehyde equilibrium conversion were studied as well,and the results were compared with the experimental data.The results provided a thermodynamic basis for the synthesis of dimethoxymethane and laid a solid foundation for study of polyoxymethylene dimethyl ethers.
Thermodynamic Analysis of Indirect Ethanol Synthesis from Syngas

Lingjun Zhu,Shurong Wang,Xinbao Li,Qianqian Yin,Zhongyang Luo

DOI: https://doi.org/10.4028/www.scientific.net/amr.433-440.457

2012-01-01

Abstract:The dependence of chemical equilibrium constant on the reaction temperature and pressure and the feed molar ratio were theoretically calculated for indirect ethanol synthesis from syngas through the coupling of CO with methyl nitrite (MN) to dimethyl oxalate (DMO) and the hydrogenation of DMO to ethanol. It shows that the coupling process and the hydrogenation of DMO to ethanol are highly favorable at all temperatures and pressures, especially at low temperature. The hydrogenation of DMO to ethylene glycol (EG) and the further reaction of ethanol with H-2 to high alcohol are thermodynamically favorable at low temperatures, below 630 and 450 K, respectively. Additionally, high reaction pressure is facilitated to EG and high alcohol formation. Accordingly, moderate reaction temperature (up 538 K) and low reaction pressure (below 1 MPa) are beneficial to ethanol production.
Thermodynamics of Ethylene Glycol Synthesis via Hydrogenation of Dimethyl Oxalate

Yin Anyuan,Dai Weilin,Fan Kangnian

DOI: https://doi.org/10.3321/j.issn:1000-8144.2008.01.012

2008-01-01

Abstract:Both standard enthalpy of formation and standard Gibbs free energy of formation of both dimethyl oxalate (DMO) and methyl glycollate was estimated by Benson group contribution method. Together with basic chemical thermodynamic data obtained from chemistry and engineer handbooks, reaction enthalpy change, reaction entropy change, reaction Gibbs free energy change and equilibrium constant of relevant reactions occurred in reaction system were calculated and analyzed. Effects of reaction temperature, reaction pressure, n(H2):n(DMO), mass fraction of DMO in methanol (wDMO) on conversion of DMO and selectivity to ethylene glycol (EG) were investigated. Under the conditions of reaction temperature 473 K, reaction pressure 2.5 MPa, n(H4)·n(DMO) 40 and WDMO ≥ 15%, both conversion of DMO and selectivity to EG exceed 99%. With further increasing of pressure, n(H2):n(DMO) and wDMO, both conversion of DMO and selectivity to EG keep steady.
Mechanism and Kinetics of Hexamethylolmelamine Methyl Etherification

Xiao-dong YAN,Qiao-lu SUN,Kai YANG,Hong FAN,Bo-geng LI

DOI: https://doi.org/10.3969/j.issn.1003-9015.2016.06.010

2016-01-01

Abstract:Hexamethoxymethyl melamine (HMMM) was synthesized through etherification of hexamethylolmelamine (HMM) with methanol using nitric acid as a catalyst. Changes of methanol concentration were determined to study the etherification process, and a kinetic model was established based on the proposed etherification mechanism. The kinetic parameters were obtained via experimental data fitting. The relationship between degree of etherification (DoE) and reaction time under different temperatures was analyzed. The results show that the etherification process is a typical reversible equilibrium reaction. The equilibrium constant of etherification increases from 1.17 to 2.79 when the temperature increases from 30℃ to 55℃ at pH 3.5. The variation of forward and reverse reaction rate constants on reaction temperature were obtained as follows: k1=8.54×106×exp(-5.39×104/RT), k2=257×exp(-2.79×104/RT). According to van 't Hoff equation, the apparent reaction enthalpy and reaction entropy for etherification are 25.97 kJ×mol-1 and 86.5 J×(mol×K)-1, respectively.
Thermodynamic Optimization of Dimethyl Ether Synthesis from Syngas in Polygeneration Systems

DUAN Yuan-yuan,LIU Jie

DOI: https://doi.org/10.3969/j.issn.1671-8097.2007.02.003

2007-01-01

Journal of Thermal Science and Technology

Abstract:Dimethyl ether(DME) has a great market potential because of its abundant physical and chemical properties.The one-through process of DME synthesis from syngas is of great importance due to its low capital cost.A thermodynamic equilibrium model was developed to simulate the synthesis process.Based on the model,the effects of temperature,pressure and the stock gas on the system performance were studied.The optimized results show that temperature is 220~260 ℃,pressure is 4~6 MPa.The equilibrium yield of DME reaches the maximum when H2/CO1,especially for the syngas converted from Jincheng No.9 anthracite,the H2/CO should be 0.75~0.8.
Thermodynamic Simulation of Direct DME Synthesis via Biomass Gasification

XiaoLan Ge,Yingying Zhu,Shurong Wang,Jinsong Zhou,Zhongyang Luo,Sai Gu

DOI: https://doi.org/10.1109/APPEEC.2010.5448512

2010-01-01

Abstract:A simulation of direct dimethyl ether (DME) synthesis from syn-gas, produced via biomass gasification and catalytic reforming, has been processed on the assumption of both physical and thermodynamic equilibrium. Simulation showed that reaction temperature, pressure and syn-gas composition are have the most important effect on DME synthesis behavior. In which, low temperature and high pressure would be advantageous for DME production.
Synthesis of dimethyl ether from greenhouse gas CO_2

Xin An,Yizan Zuo,Qiang Zhang,Jinfu Wang

DOI: https://doi.org/10.3969/j.issn.2095-2783.2007.08.006

2007-01-01

Abstract:Petroleum resource is insufficient gradually,while there is a large amount of hydrogen in industry. Production of dimethyl ether(DME) from greenhouse gas CO2 and hydrogen is a possible way to solve above problems. For the DME synthesis process from CO2 and hydrogen,thermodynamic calculations are taken to analyze the process. It indicates that the DME equilibrium yield will increase with higher operation pressure and temperature. However,a better mild operation is a feasible way to synthesize DME. To carry out this process,methanol synthesized catalysts of CD501 and dehydrating methanol catalysts of HZSM-5 are mixed together to be used as one step DME production. A fixed bed reactor is used to realize this process to pilot research the DME production. The results indicate that the DME yield will increase with higher operation temperature in the reaction process. So basic data for DME synthesis from CO2 are obtained from the thermodynamic calculation and experimental,which is a foundation for studying and exploiting the advanced and effective techniques.
Study on Synergy Effect in Dimethyl Ether Synthesis from Syngas

ZL Wang,J Diao,JF Wang,Y Jin,XD Peng

IF: 3.8

2001-01-01

Chinese Journal of Chemical Engineering

Abstract:Influence of reaction temperature, pressure and space velocity on the direct synthesis of dimethyl ether (DME) from syngas is studied in an isothermal fixed-bed reactor. The catalyst is a physical mixture of C301 copper-based methanol (MeOH) synthesis catalyst and ZSM-5 dehydration catalyst, The experimental results show that the chemical synergy between methanol synthesis reaction and methanol dehydration reaction is evident. The conversion of carbon monoxide is over 90%.
Studies on synthesis of dimethyl carbonate from methanol and carbon dioxide

Qinghai Cai,Bin Lu,Lingji Guo,Yongkui Shan

DOI: https://doi.org/10.1016/j.catcom.2008.11.002

IF: 3.51

2009-01-01

Catalysis Communications

Abstract:The reaction thermodynamics of dimethyl carbonate (DMC) synthesis from CH3OH and CO2 was investigated by estimating ΔrH and ΔrG of the reaction at different temperatures and pressure. The result shows that the reaction does not spontaneously occur under finite conditions in view of thermodynamics. Thus, in order to seek a new method or a novel idea for the DMC synthesis, the thermodynamics of DMC synthesis catalyzed by basic catalysts, K2CO3, KOH and CH3OK, was discussed in details. A general conclusion was obtained that the subroutine nesting of a coupling reaction is an effective avenue to increase the yield of DMC synthesis from CO2 and CH3OH.
Equilibrium Composition of Dimethyl Ether Steam Reforming to Hydrogen

Dongmei Feng,Jinfu Wang,Dezheng Wang

DOI: https://doi.org/10.3969/j.issn.1001-7631.2007.05.005

2007-01-01

Abstract:Thermal efficiency of dimethyl ether steam reforming (DME SR) process that heat supplied by externally or by reformate combustion were compared. The thermodynamics of hydrogen production from dimethyl ether steam reforming was calculated to study the influences of reaction temperature, pressure, feed composition on equilibrium composition. DME conversion, hydrogen and carbon monoxide selectivity were analyzed. A high conversion can be obtained at 200°C and 0.1 MPa. It was found that the hydrogen yield would be drastically decreased by the production of methane, which was more thermodynamic favored. Carbon monoxide would be favored at high temperature and low steam-DME ratio, and selective catalysts are necessary to obtain a high activity at a low temperature.
Phase Equilibrium Calculation for Binary Systems with Dimethyl Ether and the Effects on Its Separation Process

CHEN Jian,YU Yan-mei,TANG Hong-qing

DOI: https://doi.org/10.3969/j.issn.1001-9219.2005.01.017

2005-01-01

Abstract:Dimethyl ether has been recognized as a clean fuel in the new century. In this work, phase equilibrium calculation for binary systems with dimethyl ether was studied by the NRTL equation, and the effects of phase equilibria on the separation process were discussed. The main purpose of the separation process is to separation dimethyl ether and carbon dioxide. Although methanol is beneficial to increase the solubility of dimethyl ether in the liquid, the separation factor of dimethyl ether with carbon dioxide is decreased.
Density Functional Theory Study of Ethanol Synthesis from Dimethyl Ether and Syngas over Cobalt Catalyst

Xinbao Li,Shurong Wang,Yingying Zhu,Geng Chen,Guohua Yang

DOI: https://doi.org/10.1016/j.mcat.2017.02.014

IF: 4.6

2017-01-01

Molecular Catalysis

Abstract:The reaction mechanism of ethanol synthesis from dimethyl ether (DME) and syngas was studied via density functional theory calculations. Various possible pathways for ethanol formation, and byproduct formations of methanol, acetic acid, methane, carbon dioxide, and water over an active cobalt stepped surface were calculated. The most favorable pathway for ethanol synthesis starts with the dissociation of dimethyl ether to CH2, followed by carbon monoxide insertion to form CH2CO, and then undergoes successive hydrogenations to give ethanol. CH3CHO hydrogenation to CH3CHOH becomes the rate-determining step with a reaction barrier of 1.48 eV. DME decomposition and CH2 carbonylation occur easily with low barriers of 0.61 eV and 0.48 eV, respectively. Carbon monoxide insertion into CH2 is more facile than into CH3 and CH. Hydrogenation at the carbon atom occurs prior to the oxygen atom in the order of alpha-carbon > carbonyl carbon > oxygen. The calculations demonstrate that ethanol synthesis via DME carbonylation and hydrogenation is thermodynamically favored and is kinetically faster than that via syngas direct synthesis. Methane and acetic acid are two dominant competing byproducts. (C) 2017 Elsevier B.V. All rights reserved.
Thermodynamic Analysis of the Synthesis of Dimethyl Carbonate by Oxidation Carbonylation of Methanol

李忠,周丽,谢克昌

DOI: https://doi.org/10.3969/j.issn.1001-9219.2003.01.011

2003-01-01

Abstract:The standard heat of formation, free energy and heat capacity of dimethyl carbonate(DMC) are calculated by the method of group contribution. A thermodynamic analysis of synthesis process of DMC by oxidation car-bonylation of methanol was carried out with the emphasis on calculations of equilibrium constants and conversions for the reaction. The optimum reation conditions for synthysis of DMC and the possibility to eliminate various side reactions were also investigated to provide the thermodynamic basis for the design of synthesis process of DMC and the development of catalysts thereof.
Study on the Thermodynamic Properties of Liquid Fuel Substitute--Dimethyl ether

梁燕波,童景山

DOI: https://doi.org/10.3969/j.issn.1005-9954.2003.01.014

2003-01-01

Chemical engineering

Abstract:The thermodynamic properties of dimethyl ether, including PVT property, vapor pressure and latent heat of vaporization, etc. are calculated by using the theory of molecular thermodynamics. The obtained results are in good agreement with the experimental data. It shows that the proposed equations can well represent the thermodynamic behaviour of molecules for dimethyl ether. In addition, this also shows that the proposed methods may be used for engineering calculation.
Research Progress on Seperation Process for One-step Synthesis of Dimethyl Ether from Syngas

乔英云,田原宇,吕炳勇,谢克昌

DOI: https://doi.org/10.3969/j.issn.1671-9905.2015.09.006

2015-01-01

Abstract:Because of breaking up the thermodynamic equilibrium limit of methanol synthesis reaction, greatly improving conver-sion per pass of CO, and shortening the process, the one-step synthesis process of dimethyl from syngas was regarded as a promising synthesis method of dimethyl ether. The present study of the synthetic methods was more, and in the intermediate trail stage, but the research of industrial separation process matching the synthetic methods was less, which would probably become the bottleneck of restricting industrialization of the one-step synthesis process of dimethyl from syngas in the future. Based on reviewing all kinds of separation process in China and abroad for one-step synthesis process of dimethyl from syngas,this paper analyzed and classified all sorts of separation processes,then put forward the existing problems and development direction,which had certain directive significance to the further development and improvement of the new separation process.

Thermodynamic Analysis for Synthesis of Dimethyl Ether and Methanol from Synthesis Gas

Thermodynamic Analysis for Direct Synthesis of Dimethyl Ether from CO And/or CO_2 Hydrogenation

Analysis of Chemical Equilibrium in Direct Synthesis of Dimethyl Ether from Syngas

Thermodynamics of the Single-Step Synthesis of Dimethyl Ether from Syngas

Equilibrium calculations for direct synthesis of dimethyl ether from syngas

Research on a New 2-(2-Dimethylaminoethoxy) Ethanol Synthesizing Process

Thermodynamic Analysis of Dimethoxymethane Synthesis Reaction

Thermodynamic Analysis of Indirect Ethanol Synthesis from Syngas

Thermodynamics of Ethylene Glycol Synthesis via Hydrogenation of Dimethyl Oxalate

Mechanism and Kinetics of Hexamethylolmelamine Methyl Etherification

Thermodynamic Optimization of Dimethyl Ether Synthesis from Syngas in Polygeneration Systems

Thermodynamic Simulation of Direct DME Synthesis via Biomass Gasification

Synthesis of dimethyl ether from greenhouse gas CO_2

Study on Synergy Effect in Dimethyl Ether Synthesis from Syngas

Studies on synthesis of dimethyl carbonate from methanol and carbon dioxide

Equilibrium Composition of Dimethyl Ether Steam Reforming to Hydrogen

Phase Equilibrium Calculation for Binary Systems with Dimethyl Ether and the Effects on Its Separation Process

Density Functional Theory Study of Ethanol Synthesis from Dimethyl Ether and Syngas over Cobalt Catalyst

Thermodynamic Analysis of the Synthesis of Dimethyl Carbonate by Oxidation Carbonylation of Methanol

Study on the Thermodynamic Properties of Liquid Fuel Substitute--Dimethyl ether

Research Progress on Seperation Process for One-step Synthesis of Dimethyl Ether from Syngas